D.  Control Cabin Equipment
WARNING:  FAILURE TO REMOVE COVERS FROM PITOT PORTS BEFORE FLIGHT MAY CAUSE LARGE ERRORS IN AIRSPEED-SENSING AND ALTITUDE SENSING SIGNALS, WHICH MAY LEAD TO LOSS OF SAFE FLIGHT.
CAUTION:  REMOVE ALL COVERS. ENGINES SHOULD NOT BE OPERATED WITH COVERINGS IN PLACE BECAUSE THE COVERINGS CAN COME OFF AND DAMAGE THE ENGINES.
(1)  
Remove the pitot covers.

(2)  
Remove the covers from the vertical stabilizer pitot tubes.

(3)  
Remove the “PITOT PROBES COVERED” tag from the left control wheel in the flight deck.

(4)  
Remove the tape or covers from these components:

(a)  
The temperature probe

(b)  
The angle of attack sensor

(c)  
The ice detector

(d)  
The static pressure sources

WARNING:  FAILURE TO REMOVE BARRICADE TAPE AND VINYL ADHESIVE TAPE FROM THE STATIC PORTS BEFORE FLIGHT MAY CAUSE LARGE ERRORS IN AIRSPEED-SENSING AND ALTITUDE SENSING SIGNALS, WHICH MAY LEAD TO LOSS OF SAFE FLIGHT.
CAUTION:  REMOVE ALL BARRICADE TAPE AND VINYL ADHESIVE TAPE. ENGINES SHOULD NOT BE OPERATED WITH COVERINGS IN PLACE BECAUSE THE COVERINGS CAN COME OFF AND DAMAGE THE ENGINES.
(5)  
Remove all barricade tape and vinyl adhesive tape from the static ports.

(a)  Inspect each static port and if necessary use naphtha or equivalent to remove all tape residue, dirt and other contaminants around the port.

(6)  
Remove the “STATIC PORTS COVERED” tag from the left control wheel in the flight deck.

(7)  
Install the quick-opening drain valve assembly and the drain plug to the pitot and static drain tubes (Ref 34-11-01) if they were removed.

(8)  
Do a check of the portable fire extinguishers:

(9)  
Weigh the fire extinguishers.

(10)
If the weight is less than the quantity shown on the nameplate, remove the fire extinguisher and recharge or replace it.

(11)
Install the windshield wipers, if they are not installed.

(12)
Install the rain repellent bottle (Ref 30-43-0).

(13)
Make sure all the control cabin equipment installations are completed.

(14)
Do a test of the operation of the pitot-static system (Ref 34-11-01).

(15)
Do a test of the operation of the rain repellent system (Ref 30-43-0).

(16)
Do a test of the operation of the windshield wipers (Ref 30-42-0).

(17)
Drain all the pitot and static lines.

(18)
Visually examine the pitot heads and the static ports for damage of contamination.

(19)
Do an operational check of the pitot-static system instruments (Ref 34-11-01).

500 
May 01/03  BOEING PROPRIETARY - Copyright . - Unpublished Work - See title page for details.  10-12-0 Page 225 

E.  Flight Controls
(1)  
Do a check of the cable rigging loads in all of the primary and the secondary control systems, but not the Spoiler and Speed Brake Control Systems.

NOTE: See the list of all the system tests for the flight controls below.

(2)  
Adjust the cables to the correct loads if it is necessary.

(3)  
Do the operational tests of the primary and the secondary control systems as follows:

(a)  
The Aileron and Aileron Trim Control System, Operational Test (Ref 27-11-0)

(b)  
The Rudder and Rudder Trim Control System, Operational Test (Ref 27-11-0)

(c)  
The Elevator and Tab Control System, Operational Test (Ref 27-31-0)

(d)  
The Stall Warning Module, Operational Test (Ref 27-32-21)

(e)  
The Horizontal Stabilizer Trim Control System, Operational Test (Ref 27-41-0)

(f)  
The Trailing Edge Flap System, Operational Test (Ref 27-51-0)

(g)  
The Trailing Edge Flap Position Indicating System, Operational Test (Ref 27-58-01)

(h)  
The Spoiler Control System, Operational Test (Ref 27-61-0)

(i)  
The Speed Brake Control System, Operational Test (Ref 27-62-0)

(j)  
The Leading Edge Flaps and Slats System, Operational Test (Ref 27-81-0)

(k)  
The Leading Edge Flaps and Slats Position Indicating System, Operational Test (Ref 27-88-0)

(4)  
Remove unwanted lubricant applied for storage, but do not use caustic solvents, or cleaning agents.

(5)  
If it has been more than one month since the last control cable lubrication, examine, replace if necessary, and lubricate all control cables (Ref 12-26-0).

500 
10-12-0 Page 226  BOEING PROPRIETARY - Copyright . - Unpublished Work - See title page for details.  May 01/03 
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737 AMM 飛機維護手冊 PARKING AND MOORING(8)