Doc # 6.02.01 Page 1
Rev. 4 09 Jan 2003

61-CONTENTS
AMM

% Section 61-11 % Propeller Assembly - TAE 125 Diesel Engine % 1. General ..............................................1 % 2. Description............................................1 % 3. Operation.............................................3 % Trouble-Shooting % 1. General ............................................101 % Maintenance Practices % 1. General ............................................201 % 2. Remove/Install the MTV-6-A Propeller.....................201 % 3. Propeller Blade Tracking Test ...........................204
61-CONTENTS
Propeller
AMM

Section 61-20 % Propeller Control - Lycoming Engine
1.
General ..............................................1

2.
Description and Operation ................................1

Trouble-Shooting
1. General ............................................101

Maintenance Practices
1.
General ............................................201

2.
Remove/Install the Propeller Governor ....................201

3.
Remove/Install the Propeller Control Cable .................205

4.
Adjust the Propeller Control Cable........................210

Doc # 6.02.01 Page 3
Rev. 4 09 Jan 2003

61-CONTENTS
AMM

% Section 61-21 % Propeller Control - TAE 125 Diesel Engine % 1. General ..............................................1 % 2. Description and Operation ................................1
61-CONTENTS
Propeller
AMM

CHAPTER 61 PROPELLER
1. General
This Chapter tells you about the propeller installed on the DA 40.
%) Section 61-10 tells you about the propeller assembly for airplanes with the Lycoming engine % installed.
%) Section 61-11 tells you about the propeller assembly installed for airplanes with the TAE 125 % Diesel engine installed.
%) Section 61-20 tells you about the propeller governor for airplanes with the Lycoming engine % installed.
%) Section 61-21 tells you about the propeller governor for airplanes with the TAE 125 Diesel % engine installed.
For more data on the propeller refer to the propeller manufacturer’s manuals.
% Note: Equipment which is certified for installation in the DA 40 is listed in Section 6.5 of % the Airplane Flight Manual. Such equipment may be installed in accordance with % the Airplane Maintenance Manual.
% Any equipment which is not listed in Section 6.5 of the Airplane Flight Manual is % called "Additional Equipment". The installation of Additional Equipment is a % modification which must be handled in accordance with national regulations or a % Service Bulletin.
Doc # 6.02.01 Page 1
Rev. 4 09 Jan 2003

61-00-00
AIRCRAFT AMM
Propeller Governor Control Cable
Propeller
Propeller Governor
Spinner
% Figure 1: Typical Propeller Assembly
Page 2 Doc # 6.02.01 09 Jan 2003 Rev. 4
61-00-00
Propeller
AMM

Section 61-10 % Propeller Assembly - Lycoming Engine
1. General
%  The DA 40 with the Lycoming engine installed has an mt-Propeller MTV-12-B/180-17 variable pitch propeller. This propeller has 3 blades. The blades are made from wood and are covered with GFRP. The blades have an acryl lacquer painted finish. The outboard leading-edges of the blades are protected from erosion by a stainless-steel sheath. The stainless-steel sheath is bonded into position. The inboard section of the leading-edge is protected by a self-adhesive rubber strip (PU tape).
This Section tells you how to remove and install the propeller and how to do a test for blade tracking. Section 61-20 tells you about the propeller governor and how to remove/install the governor.
Refer to the propeller manufacturer’s manuals for more data on the propeller.
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：鉆石40飛機維護手冊 DA 40 SERIES AMM 4(75)