07-11-41
 ALL  ú ú 01 Page 201 ú Mar 15/96
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 LIFTING DAMAGED AIRPLANE - MAINTENANCE PRACTICES
________________________________________________
 TASK 07-12-00-582-001
 1.  Lifting Damaged Airplanes_________________________
 A. General
 (1)  Refer to the Airplane Recovery Document D6-40146 to lift an airplane that has damage.
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 07-12-00
 ALL  ú ú 01 Page 201 ú Mar 15/96
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 TILT AIRPLANE FOR TAIL CLEARANCE - MAINTENANCE PRACTICES
________________________________________________________
 1.  General_______
 A.  This procedure has these tasks:
 (1)  
Tilt the Airplane for the Tail Clearance

 (2)  
Balance Check for the Tilt Airplane

 (3)  
Tow the Tilted Airplane

 (4)  
Lower the Airplane Nose

 B.  You can lift the airplane nose with the dolly (Fig. 201) to lower the airplanes tail for clearance in the hangar or storage area.
 C.  You must add ballast when the total moment of the airplane about the main gear axle is not more than +1000 (See Fig. 211 and Fig. 213). This will keep the airplane stable when you lift the airplane nose.
 D.  You can use a nose gear ramp to permit the vertical fin to go through the hangar door.
 TASK 07-13-00-582-044
 2.  Tilt the Airplane For the Tail Clearance (Figs. 201 to 203)________________________________________
 A.  Equipment
 (1)  
D1000 - Nose Lift Dolly Mercer Robinson, Div. of Squibb Machine and Tool Co., Pennsylvania 18043 (used to lift 84 inches maximum)

 (2)  
G8950 - Nose Lift Dolly Mercer Robinson, Div. of Squibb Machine and Tool Co., Easton, Pennsylvania 18043 (used to lift 78 inches maximum)

 (3)  
F72735 - Nose and Main Landing Gear Ground Lockpins

 (4)  
C07001-1 - Shock Absorber Equipment

 B.  References
 (1)  
AMM 12-14-00/301, Passenger Water System

 (2)  
AMM 12-15-31/301, Main Landing Gear Shock Strut

 (3)  
AMM 12-15-41/301, Nose Landing Gear Shock Strut

 (4)  
AMM 28-23-00/201, Defueling

 (5)  
AMM 38-11-00/301, Passenger Water System

 C.  Prepare to Lift the Airplane
 S 652-005
 (1)  Defuel the airplane to a maximum of 18,000 lbs of fuel remaining within the limits shown in figure 206, and with no more than 6000 lbs of fuel in any one of the fuel tanks (AMM 28-23-00/201).
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 07-13-00
 ALL  ú ú 02 Page 201 ú Mar 12/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 737-300/400/500MAINTENANCE MANUAL
 (2)  S 682-006Drain the portable water and waste water tanks (AMM 12-14-00/301 and 38-11-00/301).
 (3)  S 162-007If there is snow or ice on the empennage, make sure to remove the unwanted material.
 (4)  S 682-009Inflate the nose shock strut (AMM 12-15-41/301). (a) Hold the shock strut with the nylon strap, the rope, the sling (or applicable equipment) to keep the Dimension X (Fig. 203) to 23 inches maximum. (b) Inflate the shock strut. (c) Make sure Dimension "X" is not more than 23 inches.
 (5)  S 682-010Inflate the shock struts on the main gear (AMM 12-15-31/301). (a) Make sure the extension on the shock struts is 1-1/2 |1/8 inches. 

Nose Lift Dolly
Figure 201

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 07-13-00
 ALL  ú ú 01 Page 202 ú Jul 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 LIFTING AND SHORING(11)