12-13-02
 ALL  ú ú 01 Page 303 ú Jan 28/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A

757
MAINTENANCE MANUAL

 S 413-016 CAUTION: OBEY THE PRECAUTIONS FOR THE KEVLAR WRAPPING WHEN YOU CLOSE THE
_______ FAN COWL PANEL. IF THE PRECAUTIONS ARE NOT OBEYED, DAMAGE TO THE KEVLAR WRAPPING CAN OCCUR.
 (2) Close the fan cowl panels that you opened (AMM 71-11-04/201).
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-13-02
 ALL  ú ú 01 Page 304 ú Dec 20/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A

757 MAINTENANCE MANUAL
 INTEGRATED DRIVE GENERATOR (IDG) - SERVICING
____________________________________________
 1.  General
_______
 A.  This procedure has four tasks:
 (1)  
IDG Oil Level Check.

 (2)  
IDG Oil Servicing.

 (3)  
IDG Oil Change.

 B.  There are also shorter procedures for the IDG oil servicing (Fig. 301) and the IDG oil level (Fig. 302).
 C.  Do not service a disconnected IDG.
 TASK 12-13-03-213-006
 2.  IDG OIL Level Check (Fig. 303)
___________________
 A.  General
 (1)  The IDG oil level check can be done through the IDG access panel, if the engine cowl panels are not open.
 NOTE: If the IDG low oil level indicator is missing, damaged or
____ hard to read, do the IDG oil servicing task.
 (2)  The IDG low oil level indicator shows when the oil level is below the minimum required oil level for safe operation. It does not indicate if the IDG is over serviced. The only way to ensure proper IDG oil level is to hook up the overflow drain hose and add oil to the IDG. If the oil level of the IDG is in doubt, hook up the overflow drain hose and add oil to the IDG.
 B.  References
 (1)  AMM 24-41-03/401, BPCU BITE
 C.  Access
 (1)  
Location Zones
 212 Flight Compartment
 410 Power Plant Nacelle (Left)
 420 Power Plant Nacelle (Right)

 (2)  
Access Panels
 413CL IDG Access Panel (Left Engine)
 423CL IDG Access Panel (Right Engine)

 D.  Prepare to check the IDG Oil Level
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-13-03
 ALL  ú ú 01 Page 301 ú Jan 28/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A

757
MAINTENANCE MANUAL

NOTE:____  DO NOT SERVICE IDG IF IDG IS DISCONNECTED. REFER TO 24-20-00 FAULT ISOLATION AND CORRECT "DISCONNECT TRIP" BITE MESSAGE.
STEP ONEUP
ATTACH OVERFLOW DRAIN AND PRESSURE FILL HOSES.
SOME OIL MAY COME OUT OVERFLOW DRAIN HOSE WHEN HOSE IS CONNECTED.
PUMP OIL INTO IDG UNTIL APPROXIMATELY ONE QUART OF OIL COMES OUT OVERFLOW DRAIN HOSE.
PRESSURE OVERFLOW FILL HOSE DRAIN HOSE
CONTAINER 1 QUART OIL (APPROXIMATELY)
STEP TWO
UP REMOVE PRESSURE FILL HOSE ONLY.
INSTALL COVER.
OVERFLOW DRAIN HOSE 
REMOVE OVERFLOW DRAIN HOSE WHEN DRAINAGE SLOWS TO DROPS. STEP THREE__________  UP 
INSTALL COVER.

OVERFLOW DRAIN HOSE
Summarized Servicing Procedure
Figure 301

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-13-03
 ALL  ú ú 01 Page 302 ú Dec 20/96
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
757
MAINTENANCE MANUAL

NOTE:____  DO NOT CHECK OIL LEVEL IF IDG IS DISCONNECTED. REFER TO 24-20-00 FAULT ISOLATION AND CORRECT "DISCONNECT TRIP" BITE MESSAGE.
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：757 AMM 飛機維護手冊 SERVICING 1(31)