PneumaticMinimum InterconnectingAdjustmentScrew Rod
PropellerGovernor-Right SideView Figure 511
Feather Detent  PropellerControlLevers Friction Plate
'

Propeller
Control
Feather DetentAdjustment Figure 512

EFFECTIVITY: 
040-999 
76-10-00  PAGE33Jan 10/90 

PIPER AIRCRAFT
PA-42-720(AdvancedTrainer)
MAINTENANCEMANUAL

C. EngineRun Adjustments (continued)
3. EngineRunningAdjustments(continued)
Power(Throttle)Lever
Clevis
Swivel-BallJoint
Connector

Actuating Cylinder
ActuatingCylinder Set Screws
Power (Throttle) Cable

AutofeatherSwitch Roller SupportBracketSupportBracket Jam Nuts
AutofeatherMicroswitchAdjustment
Figure 513

D. Dry EngineMotoringRun
The dry engine motoring run is used:
1.
To clear engineof trapped fuel or vaporsafter an unsuccessful enginestart.

2.
To check fuel system for leaks after a component replacement.

3.
If there is evidenceof a fire within the engine.

NOTE:  Refer to Pratt and Whitney MaintenanceManual,p/n 3034342, 71-06-20for Dry Engine Motoring Run.
E. WetEngineMotoringRun
A wet engine motoringrun is used strictlyfor engine maintenancepurposes.Itis not a part of normal enginestart procedures.
NOTE: Refer to Pratt and Whitney Maintenance Manual,p/n 3034342, 71-06-20for Wet Engine Motoring Run.
EFFECTIVITY:
040-999

Jan 10/9076-10-00 EFFECTIVITY:
PIPERAIRCRAFT PA-42-720(AdvancedTrainer) MAINTENANCEMANUAL C. EngineRunAdjustments (continued) CHART4 POWERASSURANCECHECK 
PT6A-61  POWER ASSURANCE MAXIMUMVALUES  CHECK 
550 
0  24 
450  105-
95  100-j 95 
90-
85  85-
800 
750 
700 
650  STATIC INSTALLED PROP SPEED -2000 RPM BLEED OFF 
600 
550 -40  30  -20  -10  0 OAT -C  10  20  30  40 

040-999
76-10-00Jan
109010/90

PIPER AIRCRAFT
PA-42-720(AdvancedTrainer)
MAINTENANCEMANUAL

F. Engine Performance Check
Engineperformancecheck procedures must be done periodically to detect engine performance changesand mechanical deterioration.Referto Pratt & Whitney MaintenanceManual, p/n 3034342, 71-06-20 and to Chart 4 this section, for specificcheck procedures.
NOTE: Engine instrumentationand altimeter must be correctly calibratedbefore making any power checks.
G. Engine Data Plate Speed Check
The gas generator trim speed, recorded during final engine acceptancetests,is stamped on the engine data plate. Data plate speed check curvesare used to determine desired engine performance parameters. Refer to Pratt & Whitney MaintenanceManual,p/n 3034342 and informationletter number eight for specific instructions.See Chart 4, in this manual for assurance check curves.
H. Feather Stop Adjustment
1. General
NOTE: Refer to the Pilot's OperatingHandbookfor detailed procedures and operating check lists for feathering and unfeathering a propeller while in flight.
(a) Perform the following propeller feathering check during the first flight following an engine installation:
(1.) Installed engine: Power off.
(2.) Installed engine: Propellerfeathered.
(3.) Operating engine: Maximumcontinuouspower.
(4.) Airspeed: 118 KIAS
(5.) Aircraft trimmed longitudinallyand directionally with no more than 5 degree angle of bank

into operating engine.

NOTE: Hartzell HC-B3TN-3Kpropellersareused, having external feather stops.
(b)Adjust feather stops if propellerrotateseither direction when in feathered position.
2. External Feather Stop Adjustment
(a)Location: Back side of each link arm just in front of guide collar.
(b)
Use felt tip marker to mark a location referenceacross spinner and spinner bulkhead.

(c)
Removespinner.

(d)
Refer to Figure 514. Removedomenut.

(e)
Refer to Figure 514. To gain access to feather stop adjustment alien screws, by hand, rotate propeller blades toward low pitch (high rpm) position.

(f)
Use a 5/32 alien wrench to adjust feather stop screws.

(1.) A 0.024 inch linear movement of adjustment screwchanges propeller blade angle
approximatelyonedegree. (2.) Move adjustment screwsinto piston if propeller rotatesclockwisewhenfeathered. (3.) Move adjustment screws rotates when
out of piston if propeller counterclockwise feathered.
EFFECTIVITY: PAGE 36 040-999 Jan 10/90 76-10-00
PIPER AIRCRAFT
PA-42-720(AdvancedTrainer)
MAINTENANCEMANUAL

H. Feather Stop Adjustment (continued)
2. ExternalFeather Stop Adjustment (continued)
　
中國航空網(wǎng) www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：夏延飛機(jī)維護(hù)手冊 Cheyenne IIIA PA-42-720 AMM 2(156)