(1)
 Make sure that the manual shutoff valve is in fully open position.

 (2)
 Use a 3/16 inch open wrench to operate the shaft (5) of the disk.

 (3)
 Rotate the shaft (5) of disk with the wrench to the left to a maximum of 90 deg. (1/4 turn) (left is looking in the direction of the shaft)

 NOTE : If there is too much resistance when you turn the shaft (5)
____ (normally a maximum of to 0.068 m.daN (6.01 lbf.in) force is required to turn the shaft), then the toilet assembly must be removed (Ref. TASK 38-31-41-000-001) and the orbital valve cleaned in the shop (Ref. CMM 383416). If not, breakage of the shaft may result.
 NOTE : It may be necessary to cut a small hole in the plastic foil
____ which covers the toilet bowl to let air into the bowl.
 (4)
 Make sure that the accumulated waste leaves the toilet bowl via the waste drain lines.

 (5)
 Remove the plastic foil and clean the toilet assembly and examine the cause for the blockage.

 5. Close-up
________ Subtask 38-30-00-420-060
 A. Installation of the Motor/Gear Assembly WARNING : ALWAYS WEAR RUBBER GLOVES, GOGGLES AND PROTECTIVE CLOTHES WHEN
_______
 YOU DO THIS TASK.

 (1)
 Make sure that the work area is clean and clear of tool(s) and other items.

 (2)
 Rotate the shaft (5) of the disk to the right to fully close the orbital valve.

 (3)
 Make sure that the shaft (5) aligns with the gear assembly.

 (4)
 Put the motor/gear assembly (1) in position.

 1EFF : ALL 1 38-30-00Page 206 1 1 May 01/04R 1 1 1CES 1

 (5) Install the washers (4), the lock washers (3) and the screws (2). Subtask 38-30-00-710-057
 B. Do the operational test of the vacuum toilet (Ref. TASK 38-31-00-710-009).
 Subtask 38-30-00-613-059
 C. If necessary drain and service the waste holding tank (Ref. TASK 12-16-38-613-001).
 Subtask 38-30-00-410-058
 D. Close Access
 (1)
 Make sure that the work area is clean and clear of tool(s) and other items.

 (2)
 Install the toilet shroud (Ref. TASK 25-45-22-400-001).

 (3) Close the door of the lavatory. Subtask 38-30-00-862-054
 E. De-energize the ground service network
 (Ref. TASK 24-42-00-862-001).

 1EFF : ALL 1 38-30-00Page 207 1 1 May 01/04R 1 1 1CES 1

 TASK 38-30-00-010-002

 Removal of the Toilet Drain Lines
 WARNING : DO NOT DO WORK ON THE TOILET WASTE SYSTEM AND THE POTABLE WATER
_______ SYSTEM AT THE SAME TIME. THIS WILL PREVENT CONTAMINATION OF THE POTABLE WATER SYSTEM. SUCH CONTAMINATION CAN BE DANGEROUS TO HEALTH.
 WARNING : ALWAYS USE RUBBER GLOVES WHEN YOU DO WORK:
_______
 -
ON THE TOILET WASTE SYSTEM, OR

 -
ON PARTS THAT HAVE CONTAMINATION FROM THE WASTE SYSTEM.
 WHEN YOU COMPLETE THE WORK PROCEDURE, CLEAN YOUR HANDS WITH SOAP AND
 WATER.
 THIS WILL PREVENT INFECTION (TOILET WASTE IS DANGEROUS FOR HEALTH).

 WARNING : WHEN YOU REMOVE A COMPONENT OF THE TOILET WASTE SYSTEM, ALWAYS PUT IT
_______ IN A PLASTIC BAG, THEN SEAL THE BAG. DO NOT PUT DOCUMENTS INTO THE PLASTIC BAG. SEAL THE BAG FIRST, THEN ATTACH THE DOCUMENT TO IT. THIS WILL PREVENT INFECTION (CONTAMINATION FROM TOILET WASTE CAN BE DANGEROUS TO HEALTH).
 1. Reason for the Job
__________________
 Self Explanatory
 2. Job Set-up Information
______________________
 A. Fixtures, Tools, Test and Support Equipment
 -------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific blanking plugs No specific circuit breaker(s) safety clip(s) No specific 1 ACCESS PLATFORM 3M (10 FT)- ADJUSTABLE
 1EFF : ALL 1 38-30-00Page 208 1 1 May 01/04R 1 1 1CES 1

 B. Referenced Information

 -------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
24-42-00-861-001 Energize the Ground Service Network from the External
 Power 25-54-11-000-001 Removal of the FWD Cargo-Compartment Partition FR24 25-54-12-000-001 Removal of the FWD Cargo Compartment Partition FR34 25-54-12-000-003 Removal of the Sidewall Panels in the FWD Cargo
 Compartment 25-55-11-000-001 Removal of the AFT Cargo-Compartment Partition FR47 25-55-11-000-003 Removal of the Sidewall Panels in the AFT Cargo
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM WATER/WASTE 1(106)