1EFF : ALL 1 38-32-00Page 709 1 1 May 01/05R 1 1 1CES 1
Galley Drain Valve Figure 702/TASK 38-32-00-991-003
R 1EFF : 1 1 1CES ALL 1 111 38-32-00 Page 710 May 01/05
(4)
Operate the air compressed source and blow the lines through with 0.4 Bar (6.0psi) from the inlet line at the drain valve in the direction of the sink.
(5)
If necessary clean the waste water drain lines with vinegar (Ref. TASK 38-32-00-100-001).
5. Close-up
________ Subtask 38-32-00-410-057
A. Installation of the Drain Lines
(Ref. Fig. 702/TASK 38-32-00-991-003)
(1)
Put the inlet hose (1) in position on the valve (3) and install the clamp (2).
(2)
Put the outlet hose (4) in position on the valve (3) and install the clamp (2).
(3)
Make sure that the work area is clean and clear of tool(s) and other items.
Subtask 38-32-00-942-053
B. Remove the ground support and maintenance equipment, the special and standard tools and all other items.
Subtask 38-32-00-862-055
C. De-energize the ground service network
(Ref. TASK 24-42-00-862-001)
R 1EFF : ALL 1 38-32-00Page 711 1 1 May 01/05 1 1 1CES 1
R **ON A/C 004-049, 053-099, 101-149, 151-199, 201-299, 301-399, 401-499,
TASK 38-32-00-100-002 Cleaning of the Filter-Element of the Washbasin Drain-Valve Assembly
1. Reason for the Job
__________________
Refer to the MPD TASK: 383200-01
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific hooks No specific vinegar
B. Expendable Parts
-------------------------------------------------------------------------------FIG.ITEM |DESIGNATION |IPC-CSN -------------------------------------------------------------------------------
2 O-ring 38-32-42 02C-080 3 filter 38-32-42 02C-090
C. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
24-42-00-861-001 Energize the Ground Service Network from the External Power 24-42-00-862-001 De-energize the Ground Service Network Supplied from the External Power 38-32-00-991-002 Fig. 703
R 1EFF : 004-049, 053-099, 101-149, 151-199, 1 38-32-00Page 712 1201-299, 301-399, 401-499, 1Aug 01/05 1 1 1CES 1
3. Job Set-up
__________
Subtask 38-32-00-861-053
A. Energize the aircraft electrical circuits
(Ref. TASK 24-42-00-861-001).
Subtask 38-32-00-010-053
B. Removal of the Filter
(Ref. Fig. 703/TASK 38-32-00-991-002)
(1)
Open the lavatory door.
(2)
Remove the filter from the waste water-drain assembly
(a)
Remove the stopper (5).
(b)
Remove the strainer plug (1).
(c)
If you cannot remove the strainer plug (1) easily, use two hooks opposite of each other and pull it out.
(d)
Remove the filter (3).
(e)
Remove and discard the O-ring (2).
4. Procedure
_________ Subtask 38-32-00-110-051
A. Clean the Filter of the Waste Water-Drain Assembly
(Ref. Fig. 703/TASK 38-32-00-991-002)
WARNING : ALWAYS WEAR RUBBER GLOVES, GOGGLES AND PROTECTIVE CLOTHES WHEN
_______
YOU DO THIS TASK.
(1)
Put the filter (3) of the waste water drain-assembly in vinegar for approximately 30 min.
(2)
Clean the filter (3) with clean water.
(3)
Use dry compressed air to fully dry the filter.
(4)
Examine the filter for damage, if necessary replace the filter (3).
R 1EFF : 004-049, 053-099, 101-149, 151-199, 1 38-32-00Page 713 1201-299, 301-399, 401-499, 1Aug 01/05 1 1 1CES 1
Filter of the Waste Water Drain - Assembly
Figure 703/TASK 38-32-00-991-002
R 1EFF : 004-049, 053-099, 101-149, 151-199, 1 38-32-00Page 714 1201-299, 301-399, 401-499, 1Aug 01/05 1 1 1CES 1
5. Close-up
________ Subtask 38-32-00-410-055
A. Installation of the Filter in the Waste Water Drain-Assembly
(Ref. Fig. 703/TASK 38-32-00-991-002)
(1)
Make sure that the waste water drain-assembly is clean.
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM WATER/WASTE 2(121)
