(2)  
Install the upper wing leading edge cover 521FT/621FT.

 (3)  
Install the strut forward fairing No. 3 451B/481B.

 (4)  
Open and unlock the aft fairing panels 454AL/484AL.

 S 412-135
 S 412-332
 S 412-137
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 54-53-00
 ALL  ú ú 01N Page 227 ú Jun 10/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 S 442-138
 WARNING: MAKE SURE THAT PERSONS AND EQUIPMENT ARE CLEAR OF THE LE AND TE
_______ FLAPS AND FLAP DRIVE MECHANISMS BEFORE YOU MOVE THE FLAP CONTROL LEVER. WITH HYDRAULIC POWER REMOVED, THE FLAPS WILL MOVE AUTOMATICALLY BY ELECTRICAL POWER WHEN YOU MOVE THE FLAP CONTROL LEVER. THIS CAN CAUSE INJURY TO PERSONS OR DAMAGE TO EQUIPMENT.
 WARNING: YOU MUST CAREFULLY DO THE STEPS IN THE TASK BELOW TO REMOVE THE
_______ LE FLAP SAFETY LOCK. THE LE FLAPS CAN MOVE QUICKLY IF YOU DO NOT DO THE STEPS CORRECTLY. THIS CAN CAUSE INJURY TO PERSONS OR DAMAGE TO EQUIPMENT.
 (5)  Do this task: "Safety Locks Removal and Extended Leading Edge Flaps Activation" (AMM 27-81-00/201).
 S 412-140
 WARNING: OBEY THE INSTRUCTIONS IN THE PROCEDURE TO CLOSE THE THRUST
_______ REVERSERS. IF YOU DO NOT OBEY THE INSTRUCTIONS, INJURIES TO PERSONS AND DAMAGE TO EQUIPMENT CAN OCCUR.
 (6)
Close the left and right thrust reversers (AMM 78-31-00/201).

 S 412-361

 (7)
Close the left and right core cowl panels (AMM 71-11-06/201).

 S 412-141

 (8)
Close the left and right fan cowl panels (AMM 71-11-04/201).

 S 442-362

 (9)  
Do the activation procedure for the thrust reverser
 (AMM 78-31-00/201).

 TASK 54-53-00-702-142
 7.  Outboard Strut, Closure Spar - Leak Check (S4)______________________________________________
 A. General
 (1)  This task gives instuctions on how to do a leak check (S4) of the closure spar structure on the outboard strut.
 B. Equipment
 (1)  Water source - low pressure, can spray up to 2 quarts (1.9 liters) per minute
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 54-53-00
 ALL  ú ú 01N Page 228 ú Jun 10/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 (2)  
Container - 5 gallon (19 liter) capacity, can collect and measure water to within 1 fluid ounce (30 ml) (measure can be done in smaller containers)

 (3)  
Funnel - long necked

 C. References
 (1)  
AMM 08-00-00/201, Leveling and Weighing

 (2)  
AMM 27-81-00/201, Leading Edge Flaps

 (3)  
AMM 51-31-01/201, Seals and Sealing

 (4)  
AMM 54-62-00/201, Nacelle Strut Access Panels

 (5)  
AMM 71-11-04/201, Fan Cowl Panels

 (6)  
AMM 71-11-06/201, Core Cowl Panels

 (7)  
AMM 78-31-00/201, Thrust Reverser System

 D. Access
 (1)  Location Zone
 451 Nacelle Strut 1 - Forward Fairing
 452 Nacelle Strut 1 - Torque Box
 481 Nacelle Strut 4 - Forward Fairing
 482 Nacelle Strut 4 - Torque Box

 Access Panel 452FL Spring Beam Bearing Access Door Panel - Engine 1 452GL Spring Beam Pin Access Door Panel - Engine 1 454AL Aft Fairing Door Panel - Engine 1 521FT Wing Leading Edge Cover - Engine 1 482FL Spring Beam Bearing Access Door Panel - Engine 4 482GL Spring Beam Pin Access Door Panel - Engine 4 484AL Aft Fairing Door Panel - Engine 4 621FT Wing Leading Edge Cover - Engine 4
 E. Prepare for the Leak Check
 S 042-343
 WARNING: DO THE DEACTIVATION PROCEDURE TO PREVENT THE OPERATION OF THE
_______ THRUST REVERSER. THE ACCIDENTAL OPERATION OF THE THRUST REVERSER CAN CAUSE INJURIES TO PERSONS AND DAMAGE TO EQUIPMENT.
 (1)  
Do the deactivation procedure for the thrust reverser for ground maintenance (AMM 78-31-00/201).
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 NACELLES/PYLONS(65)