曝光臺 注意防騙 網曝天貓店富美金盛家居專營店坑蒙拐騙欺詐消費者

strong aciduous or alkaline
chemicals
In general, cleaning of an aluminium
vehicle is not different
from cleaning any other vehicle.
It can be done on automatic
washing lines as well as manually
with the use of high pressure
spray guns, brushes and cloths.
1. Introduction
Commercial vehicle cleaning station (Interservice Arras)
154
ALUMINIUM IN COMMERCIAL VEHICULES CHAPTER XII CLEANING OF ALUMINIUM COMMERCIAL VEHICLES 154 | 155
Stains on commercial vehicles
may have the following origins:
• Road caused: dirt, salts, mud,
water splash, tyre wear
• Fuel caused: diesel exhaust, soot
• Load caused: cement, asphalt,
chalk, residues of agricultural
products etc.
• Environmentally caused: effects
of air pollution, dust
All these elements, in connection
with humidity, can lead to local
corrosion and fading or destruction
of the paint layer.
In this respect, residues of previously
transported goods prior to
a new load might also be seen as
contamination and require intensive
cleaning.
2. The nature
of stains
The detergent used for cleaning an
aluminium vehicle must be compatible
with aluminium, means it
must not be too aggressive.
In general, a detergent has to:
• Have a strong effect on all
kinds of dirt
The cleaning of a vehicle should
not take place in direct sunlight.
Each detergent should be tested
on a raw aluminium surface prior
to first use.
The detergent can be used either
in automatic washing lines or can
be applied manually with the use
of high pressure spray guns,
brushes, cloths etc. Its main
cleaning effects are:
• Chemical
Some elements of the detergent
dissolve the dirt or mineral salts
without attacking the surface
3. The choice
of detergent
• Allow an efficient removal of
aggressive dirt
• Create a bright visual appearance
of the surface
• Build up a protective film on
top of the paint
• Be in compliance with specific
regulations
• Be biologically degradable
• Be harmless to the user
Detergents are a complex mixture
of up to 20 ingredients to
enable diverse functions at the
same time: degreasing, slight
etching, washing, conserving etc.
4. Application
of the detergent
• Physical
Stains are removed by decreasing
the surface tension. Therefore detergents
contain wetting elements
• Mechanical
Stains are removed by spraying
with pressurised detergent or by
abrasion when using brushes
• Temperature
Higher temperatures, or even
water steam, increase the cleaning
effect by increasing the speed
of the chemical reaction between
the detergent and the stain.
Spraying should be done from
bottom to top of the vehicle to
prevent streaking. The residence
time should be sufficient to dissolve
the stains. The detergent
should not dry on the vehicle surface
and washing should be followed
by intensive rinsing with
de-ionized water.
155
EEUURROOPPEEAANN AALLUUMMIINNIIUUMM AASSSSOOCCIIAATTIIOONN
156
1. FOREWORD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
2. EXECUTION OF REPAIR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
3. REPAIR OF ALUMINIUM CHASSIS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
4. MIG AND TIG WELD REPAIRS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
4.1. Choice of alloy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
4.2. Preparations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
4.3. Welding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
CHAPTER XIII
REPAIR OF ALUMINIUM
COMMERCIAL VEHICLES
157
EUROPEAN ALUMINIUM ASSOCIATION
1. Foreword
Repair of commercial vehicles
should be done with the same
care as new construction. In
general, all rules, materials and
methods used for new construction
should also be applied for
repair causes.
Repair is a case-to-case decision,
whether small damaged parts
can be repaired without disassembling
the structure or
whether damaged components
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：航空資料25(51)