(16)
 Do an interphone communication test between the cockpit and the ground service personnel (Ref. TASK 23-44-00-700-001).

 (17)
 Pressurize the pneumatic system:

 -with the APU (Ref. TASK 12-33-21-618-001) or with the HP ground-air supply unit (Ref. TASK 12-33-21-618-001).
 NOTE : You must close the access door 811 for this procedure.
____
 Subtask 05-53-00-970-051
R C. Calculation of the Pressure.
 (1)
 Use the pressure indicator to measure the ambient pressure (Pamb).

 (2)
 Calculate and write the values below:

 -
Value A = Pamb + 300 mbar (4.35 psi)

 -
Value B = Pamb + 550 mbar (7.97 psi)

 4. Procedure
_________

 Subtask 05-53-00-780-051
 A. Test at a Differential Pressure of 550 mbar (7.97 psi)
 WARNING : DO NOT LET THE CABIN ALTITUDE CHANGE TOO FAST. SUDDEN CHANGES
_______
 IN PRESSURE CAN CAUSE INJURY TO PERSONS.

 WARNING : MAKE SURE THAT THE DIFFERENTIAL PRESSURE IS NOT MORE THAN THE
_______
 VALUE SPECIFIED FOR THIS TEST.

 WARNING : DO NOT USE THE ECAM DISPLAYS TO READ THE CABIN PRESSURE
_______ PARAMETERS (CABIN DIFFERENTIAL PRESSURE, CABIN ALTITUDE, CABIN VERTICAL- SPEED) DURING THIS TEST. THE PRESSURES USED IN THIS TEST ARE MORE THAN THE MAXIMUM LIMIT OF THE RELATED PRESSURE SENSOR. WHEN THESE PRESSURES BECOME MORE THAN THE PRESSURE SENSOR LIMIT, ON THE ECAM DISPLAY:
 -
THE CABIN DIFFERENTIAL PRESSURE INDICATION BECOMES AMBER XX

 -
THE CABIN ALTITUDE INDICATION BECOMES AMBER XX

 -
THE CABIN VERTICAL-SPEED INDICATION IS NO LONGER CORRECT. IF YOU DO NOT KNOW THE CORRECT CABIN PRESSURE VALUES, YOU CAN MAKE UNWANTED CHANGES IN PRESSURE THAT CAN CAUSE INJURY.

 NOTE : This procedure uses the MAN V/S CTL switch on the CABIN PRESS
____ section of the panel 25VU to control the cabin pressure. This switch, spring loaded to neutral, controls the outflow valve position:
 -UP: the outflow valve moves to the open position (the cabin pressure decreases)
 -DN: the outflow valve moves to the closed position (the cabin
 pressure increases)
 We recommend:

 -short action on this switch (do not hold the switch in the UP or DN position)
 -that you monitor the cabin vertical speed indication to prevent sudden changes in cabin pressure.
 1EFF : ALL 1 05-53-00Page 521 1 1 Feb 01/00R 1 1 1CES 1

 -------------------------------------------------------------------------------
ACTION RESULT -------------------------------------------------------------------------------
1. On the AIR COND panel 30VU:
 -adjust the cabin temperature control as necessary.
 2. On the CABIN PRESS section of the panel 25VU:
 -set the MAN V/S CTL switch to DN and release, the switch moves to the neutral position. Do this operation several times. This closes the outflow valve.
 NOTE : The cabin vertical speed
____ must not be more than 500 ft.min (152.39 m.min).
 -stop when you get a cabin pressure of Value A (Pamb + 300 mbar (4.35 psi)).
 3. With the MAN/V/S CTL switch in the UP or DN position, keep the pressure stable at value A (Pamb
 + 300 mbar (4.35 psi)) for 15 minutes.
 On the AIR COND panel 30VU:
 -make sure that the FAULT legends of the PACK 1 and PACK 2 pushbutton switches is off.
 Air blows into the fuselage.
 On the vertical speed indicator:
 -The cabin vertical speed must not be
 more than 500 ft.min (152.39 m.min). On the pressure indicator:
 -the cabin pressure increases to value A (Pamb + 300 mbar (4.35 psi)).
 Tell ground personnel to do a precheck of the repaired area. On the vertical speed indicator:
 1EFF : ALL 1 05-53-00Page 522 1 1 Feb 01/00R 1 1 1CES 1

 -------------------------------------------------------------------------------
ACTION RESULT -------------------------------------------------------------------------------
4. Use the same method as in step 2 to increase cabin pressure to value B (Pamb + 550 mbar (7.97 psi)).
 NOTE : The cabin vertical speed
____ must not be more than 500 ft.min (152.39 m.min).
 5. With the MAN/V/S CTL switch in the UP or DN position, keep the pressure stable at value B (Pamb
 + 550 mbar (7.97 psi)).
 6.
 Apply the leak-detection soap solution to find leaks.

 7.
 On the CABIN PRESS section of the panel 25VU:

 -with the MAN V/S CTL switch, decrease the cabin pressure until you get a differential pressure of 0 psi.
 -
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM 時間限制/維護檢查 4(143)