35-22-21
 ALL  ú ú 03 Page 403 ú Jul 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 S 024-012
 (2)  
Remove the mounting screws.

 S 024-020

 (3)  
Remove the door latch actuator.

 TASK 35-22-21-404-013
 3.  Door Latch Actuator Installation (Fig. 401-402)________________________________
 A. References
 (1)  
AMM 35-22-31/201, Passenger Oxygen System

 (2)  
AMM 35-22-00/501, Passenger Oxygen System

 (3)  
AMM 25-23-61/201, Cabin Interior

 B. Access
 (1)  Location Zones
 100 Upper Half of the Fuselage

 C. Procedure
 S 424-014
 (1)  
Put the actuator in its position and install the mounting screws.

 S 434-015

 (2)  
Connect the electrical wires.

 D. Close the Access to the Actuator
 S 414-016
 (1)  
On the passenger service unit, make sure the passenger service unit door is correctly closed and latched (AMM 25-23-61/201).

 S 414-017

 (2)  
On the attendant's and the lavatory mask boxes, do the steps that follow:

 (a)  
Lift the mask box into its position and install the mounting screws as shown in Fig. 402.

 (b)  
Pack the oxygen masks (AMM 35-22-31/201).

 E. Put the Airplane Back to Its Usual Condition
 S 864-018
 (1) Remove the DO-NOT-CLOSE tags and close these circuit breakers:
 (a)  P18-3 Panel
 1) 3F8, OXYGEN SYSTEM PASS R or
 PASS OXYGEN RIGHT

 2)  3F9, OXYGEN SYSTEM PASS L or PASS OXYGEN LEFT
 S 714-019
 (2)  Use the manual actuation test and test the passenger oxygen system (AMM 35-22-00/501).
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 35-22-21
 ALL  ú ú 04 Page 404 ú Nov 12/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 OXYGEN MASKS - MAINTENANCE PRACTICES
____________________________________
 1.  General_______
 A.  Do this procedure when the oxygen masks are removed from the passenger service units. When you do this procedure, the oxygen box must be fully and correctly installed.
 B.  This procedure gives the instructions to put the oxygen masks of the passenger service units into coils. These masks are installed through the open top of the mask box. These mask boxes contain three or four oxygen masks.
 C.  This procedure gives the instructions to put the oxygen masks of the attendant and lavatory mask boxes into coils. These masks are installed through the open mask box door. These mask boxes contain two oxygen masks.
 TASK 35-22-31-402-001
 2.  PSU Oxygen Mask Installation____________________________
 NOTE: Before you install the oxygen masks, make sure the mask hoses
____ (tubing) are serviceable. Replace the mask assembly when it is necessary.
 A.  Standard Tools and Equipment
 (1) Rod or Tool - 0.125 inch diameter.
 B.  References
 (1)
AMM 20-10-27/201, Heat Guns, Soldering Guns and Soldering Irons

 (2)
AMM 35-22-11/401, Oxygen Generator

 C.  Access
 (1)  Location Zone
 100 Upper Half of the Fuselage

 D.  Prepare to Install the Oxygen Masks
 S 012-036
 WARNING:_______WHEN YOU PACK THE MASKS, DO NOT PULL THE LANYARDS. TOO MUCH PRESSURE ON THE LANYARDS WILL RELEASE THE FIRING PIN AND FIRE THE GENERATOR. IF THE RELEASE PIN IS PULLED AND THE GENERATOR FIRES THE SURFACE TEMPERATURE OF THE GENERATOR CAN BE MORE THAN 450°F AND CAN BURN YOU. DO NOT TOUCH THE GENERATOR UNTIL IT IS COOL.
 (1)
Lower the service unit (AMM 25-23-61/201).

 S 422-003

 (2)
To remove the mask box cover, do the step that follows:

 (a) Carefully lift the cover away from the mask box.
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
　
中國航空網(wǎng) www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機(jī)維護(hù)手冊 氧氣 OXYGEN(50)