0 10 20 30 40 50 60 70 80 90100
N1(%)
WHEN THE ENGINE THROTTLE IS RETARDED AND THE ENGINE BLEED SYSTEM SWITCHOVER OCCUR FROM
5TH-STAGE PRESSURE TO 9TH-STAGE PRESSURE, DUCT PRESSURE CAN DECAY TO AS LOW AS 20 PSIG
BEFORE THE HIGH STAGE VALVE OPENS AND REGULATES THE DUCT PRESSURE TO A NOMINAL 32 PSIG.
Duct Pressure vs N1 at Sea Level and 5000 Feet
Figure 102
A50371
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
36-11-05
ALL ú ú 01 Page 105 ú Mar 15/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 737-300/400/500MAINTENANCE MANUAL
60
DUCT PRESSURE (PSIG)
50
40
30
20
10
0
0 102030405060
N1(%)
Duct Pressure vs N1 at Sea Level and 10,000/22,000/37,000 Feet
Figure 102A
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
36-11-05
ALL ú ú 02 Page 106 ú Nov 15/97
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
G96134
A
737-300/400/500MAINTENANCE MANUAL
PREREQUISITES
B1,B2,B3,D1,D2,D3,D4 MAKE SURE THESE CIRCUIT BREAKERS ARE CLOSED (P6-4):
NO PRESSURE IN THE PNEUMATIC SYSTEM (AMM 36-00-00/ ELECTRICAL POWER IS ON (AMM 24-22-00/201) 201) MAKE SURE THE AIRPLANE IS IN THIS CONFIGURATION: APPLICABLE ENGINE BLEED SWITCH (P5 PANEL) IN THE OFF POSITION
THE "BLEED TRIP OFF" PRESSURE GAUGES (2 REQUIRED) PRESSURE REGULATOR NEEDLE VALVE 0-200 PSIG GAS SOURCE (NITROGEN BOTTLE) EQUIPMENT:
BLEED SOURCE. THE ENGINE WAS THE LIGHT WAS ON. ____NOTE: SYSTEM BACK TO THE NORMAL CONFIGURATION. RESET BUTTON ON THE P5 PANEL TO PUT THE BLEED AT THE END OF THE PROCEDURE, PUSH THE TRIP
NO
YES
21 OPEN THE FAN COWL PANELS AND THRUST REVERSER HALVES(AMM 71-11-02/201).
DISCONNECT CONNECTOR D3064
YES FROM THE BLEED AIR REGULATOR
(SEE SHEET 6).
SEE SHEET 2 PUSH THE TRIP RESET BUTTON
(BLOCK 2)ON THE P5 PANEL. IS THE LIGHT OFF?
NO SEE SHEET 2 (BLOCK 22)
The BLEED TRIP OFF Light Was On. The Engine Was the Bleed Source.
Figure 103 (Sheet 1)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
36-11-05
ALL ú
ú 02 Page 107
ú Nov 15/97
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A47977
A
737-300/400/500MAINTENANCE MANUAL
FROM SHEET 1 FROM SHEET 1 (BLOCK 1) (BLOCK 21)
YES
NO
YES
22 DISCONNECT CONNECTOR D526 (ENGINE 1), D528 (ENGINE 2) FOR THE ENGINE BLEED AIR OVERHEAT SWITCH (490`F)(SEE SHEET 6).
PUSH THE TRIP RESET BUTTON ON THE P5 PANEL. IS THE LIGHT OFF?
NO
YES
2 OPEN THE FAN COWL PANEL 44 REMOVE THE PRESSURE FROMAND THRUST REVERSER HALVES THE SYSTEM. (AMM 71-11-02/201). REPLACE THE BLEED AIR
DISCONNECT THE 5TH-STAGE REGULATOR (AMM 36-11-16/401). SUPPLY LINE AT THE INLET TOTHE TEE.
CONNECT A PRESSURE GAUGE (0-200 PSIG, Ps), A PRESSUREREGULATOR, AND A NITROGEN SOURCE AT THE INLET TO THE TEE (SEE SHEET 7).
INCREASE Ps TO 165 PSIG AND EXAMINE THE BLEED TRIP OFFLIGHT ON THE P5 PANEL.
____ THIS MAKES SURE THE
NOTE: OVERPRESSURE SWITCH DOES NOT PERMIT THE BLEED TRIP OFF LIGHT TO COME ON AT PRESSURES BELOW THE CORRECT RANGE.
DID THE BLEED TRIP OFF LIGHT COME ON?
NO YES
3 NOTE:
WITH AN EXCESSIVE THE SYSTEM.
LEAKAGE ACROSS THE REPLACE THE HIGH-STAGE
BUTTERFLY VALVE CAN VALVE (AMM 36-11-85/401).
CAUSE THE BLEED
TRIP OFF LIGHT TO
COME ON DURING A NO
BLEEDS TAKEOFF.
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 PNEUMATIC(19)
