TASK 12-11-10-603-040
 2. Wing Tank Fuel Sumping Procedure (Fig. 301)
________________________________
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-11-10
 ALL  ú ú 03 Page 302 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

NO. 2 RESERVE TANK SURGE TANK
CENTER WING TANK NO. 1 MAIN TANK
SUMP DRAIN  SUMP DRAIN
SUMP DRAINS SUMP DRAIN

Wing Tank Fuel Sump Drainage
Figure 301

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-11-10
 ALL  ú ú 01 Page 303 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 A. References
 (1)  
AMM 12-33-01/301, Cold Weather Maintenance

 (2)  
AMM 28-11-00/701, Fuel Tanks

 (3)  
Boeing Service Letter 747-SL-28-081A, Red Dye Contamination

 B. Equipment
 (1) MIT65B00772 - Receptacle Assembly, Fuel Sump Drain, or equivalent
 C. Access
 (1)  
Location Zones
 130 Center Wing Tank
 500 Left Wing
 600 Right Wing

 (2)  
Access Panels
 191G Fuel Drain and Dripstick Access Door
 192G Fuel Drain and Dripstick Access Door

 D. Prepare for the Procedure
 S 683-041
 (1)  If the ambient temperature is less than 0 degree Celsius (32 degrees Fahrenheit), do this task: Cold Weather Maintenance (AMM 12-33-01/301).
 NOTE: Supply heat before you drain the sumps to make sure the fuel
____
 drains freely.

 S 683-042
 (2)  
Permit the water to go to the bottom of the tank before you open the sump drain valve.

 S 683-043

 (3)  
If it is necessary to get a fuel sample from the center wing tank sump, open access doors 191G and 192G.

 E. Sump the Main, Center and Reserve Tanks
 S 683-044
 (1)  
Put the top end of the receptacle assembly against the sump drain poppet.

 (2)  
Put the container below the sump drain valve.

 S 683-045
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 12-11-10
 ALL  ú ú 03 Page 304 ú Oct 18/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 S 683-046
 (3)  Push up until the fluid flows into the container.
 NOTE: If you can not open the sump drain valve or fluid does not
____ drain from the valve, water around the valve or in the valve can be frozen. Do the applicable cold weather maintenance (AMM 12-33-01/301).
 S 683-047
 (4)  
Drain each sump until the container is full.

 S 683-048

 (5)  
Remove the sample container from the sump and permit the valve to close.

 S 683-049

 (6)  
Look at the fuel in the container.

 S 683-050

 (7)  
If the fuel in the container has visible water (free water), do these steps:

 (a)  
Empty the fuel from the container.

 (b)  
Use the correct procedures to dispose of the fuel.

 (c)  
Continue to drain fuel from the sump drain until all of the free water is removed.

 S 683-051
 (8)  If the water in the fuel sample container has a foul odor or a brown color, do this task: Detection Test for Microbial Contamination (AMM 28-11-00/701).
 S 683-052
 CAUTION: IF YOU FIND THAT THE FUEL HAS A RED OR A PINK COLOR, DO THE
_______ APPLICABLE CHECK TO MAKE SURE THE FUEL IS NOT CONTAMINATED. DAMAGE TO EQUIPMENT CAN OCCUR.
 (9)  
If you see red dye in the fuel, do this task: Clean the Fuel Tanks Contaminated with Red Dye (AMM 28-11-00/701).
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 SERVICING 1(33)