CAUTION:_______DISCARD THE HUB HOLDDOWN BOLT. THE BOLT CAN BECOME LOOSE IF YOU USE THE BOLT AGAIN.

 (g)  
Install a new hub holddown bolt and the flat washer. 1) Tighten the hub holddown bolt to 20-30 inch-pounds.

 (h)  
Tighten the hub clamping screw to 60-100 inch-pounds.

 (i)  
Do the Wiper Arm Pressure Adjustment/Test paragraph.

 H. Procedure - Wiper Arm Pressure Adjustment/Test
 S 915-047
 CAUTION:_______DO NOT OPERATE THE WIPERS ON A DRY WINDSHIELD. THE WINDSHIELD CAN BE DAMAGED BY THE WIPER MOVEMENT.
 (1)  
Supply water to keep the windshield wet when the wipers are in operation.

 S 865-030

 (2)  
Put the WIPER switch on the P5 panel in the LOW position.

 S 865-031

 (3)  
Open these circuit breakers on the P11 panel and attach DO-NOT-CLOSE tags to stop the windshield wipers in midstroke:

 (a)  
11R13, WSHLD WIPER LEFT

 (b)  
11R22, WSHLD WIPER RIGHT

 (4)  
Stop the flow of water to the windshield.

 S 485-033

 (5)  
Connect a spring scale at the place where the wiper blade is attached to the arm.

 S 915-032
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 30-42-00
 ALL  ú ú 02 Page 506 ú May 28/02

A 757 MAINTENANCE MANUAL
COUNTER BORE FOR

ADJUSTMENT SLEEVE SLOT
BUSHING MOVEMENT ONE TOOTH BETWEEN OUTPUT SHAFT AND BUSHING  APPROXIMATELY 2 3/4 INCHES MOVEMENT AT BLADE ATTACHMENT POINT 
ONE TOOTH BETWEEN BUSHING AND HOUSING  APPROXIMATELY 3 1/4 INCHES 
AND BUSHING, THEN TOOTH COUNTERCLOCKWISE BETWEEN BUSHING AND HOUSING ONE TOOTH CLOCKWISE BETWEEN OUTPUT SHAFT  APPROXIMATELY 1/2 INCH 

APPROXIMATE MOVEMENT CORRELATION CHART

PUT THE SLOTS LESS THAN 90` APART WHEN YOU INSTALL THE WIPER ARM HUB TO THE ADJUSTMENT SLEEVE
Windshield Wiper Arm and Blade - Adjustment
Figure 502

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 30-42-00
 ALL  ú ú 03 Page 507 ú Jun 20/94

E29675
A
757 MAINTENANCE MANUAL
 S 735-034
 CAUTION:_______DO NOT LIFT THE ARM TOO FAR. IF YOU LIFT THE ARM TOO FAR, DAMAGE TO THE ARM CAN OCCUR.
 (6)  
Slowly pull the scale perpendicular from the windshield surface, until the arm is off of the windshield surface or touches at only one tip. Make sure the scale indicates 15 |1 pounds.
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：757 AMM 飛機維護手冊 防冰和排雨 CHAPTER 30 - ICE AND RAIN PROTECTION(135)