(7)
Put a blanking plug on the gearbox housing.
R EFF : 001-049, 101-105, 107-107, 151-199, 49-42-52Page 403 201-210, Config-2 Aug 01/05
CES
Clutch - Starter Motor
Figure 401/TASK 49-42-52-991-005
CES
TASK 49-42-52-400-003
Installation of Starter Motor Clutch (8033KM) (131-9(A))
1. Reason for the Job
__________________
Self Explanatory
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific Torque Wrench : range 0.20 to 3.60 m.daN
(2.00 to 26.00 lbf.ft)
B. Consumable Materials
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 03-002 GB DEF-STAN 91-101 LUBRICATING OIL TURBINE ENGINE SYNT BASE (Ref. 20-31-00)
C. Expendable Parts
-------------------------------------------------------------------------------FIG.ITEM |DESIGNATION |IPC-CSN -------------------------------------------------------------------------------
packing 49-42-09 01 -070
R EFF : 001-049, 101-105, 107-107, 151-199, 49-42-52Page 405 201-210, Config-2 Aug 01/05
CES
D. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
24-42-00-861-001 Energize the Ground Service Network from the External Power 24-42-00-862-001 De-energize the Ground Service Network Supplied from the External Power 29-00-00-864-001 Put the Related Hydraulic System in the Depressurized Configuration before Maintenance Action 29-14-00-614-002 Pressurization of the Hydraulic Reservoirs through
the Ground Connector 49-42-51-400-004 Installation of the Starter Motor (131-9(A)) 49-42-51-700-002 Test of the Starter Motor (131-9(A)) 52-41-00-010-001 Open the APU Doors for Access 52-41-00-410-001 Close the APU Doors after Access 49-42-52-991-005 Fig. 401
3. Job Set-up
__________
Subtask 49-42-52-860-057
A. Aircraft Maintenance Configuration
(1)
Energize the ground service network
(Ref. TASK 24-42-00-861-001).
(2)
On the panel 25VU, make sure that the APU MASTER SW p/bsw is OFF.
(3)
Make sure that there is a warning notice in the cockpit to tell persons not to start the APU.
(4)
Make sure that hydraulic systems are depressurized
(Ref. TASK 29-00-00-864-001).
(5)
Make sure that the access platform is in position below the APU compartment.
(6)
Make sure that the APU access doors are open (Ref. TASK 52-41-00-010-001).
(7)
Set the LIGHT SW 11LJ to the ON position.
R EFF : 001-049, 101-105, 107-107, 151-199, 49-42-52Page 406 201-210, Config-2 Aug 01/05
CES Subtask 49-42-52-865-057
B. Make sure that this(these) circuit breaker(s) is(are) open, safetied and tagged
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------121VU APU/APU/CTL 2KD L42 121VU APU/ECB/SPLY 1KD L41
4. Procedure
_________ Subtask 49-42-52-420-056
A. Install the Starter Motor Clutch
(Ref. Fig. 401/TASK 49-42-52-991-005)
(1)
Remove the blanking plug from the gearbox housing.
(2)
Apply a thin layer of lubricant OILS (Material No. 03-002) to the new packing (5) and install it on the cover (4).
(3)
Install the clutch (7) in the gearbox housing.
(4)
Install the wave-spring washer (6).
(5)
Position the cover (4).
(6)
Install the bolts (1) and washers (2) to secure the cover.
(7)
Install the V-clamp (3) with the bolt (1) and the washer (2).
(8)
TORQUE the bolts (1) to 1.4 m.daN (10.32 lbf.ft). Subtask 49-42-52-410-054
B.
Install the starter motor (Ref. TASK 49-42-51-400-004). Subtask 49-42-52-710-053
C.
Test the starter motor. (Ref. TASK 49-42-51-700-002)
R EFF : 001-049, 101-105, 107-107, 151-199, 49-42-52Page 407 201-210, Config-2 Aug 01/05 中國航空網 www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM 機載輔助動力 AIRBORNE AUXILIARY POWER4(115)
