R 1EFF : 001-049, 051-052, 054-099, 101-149, 1 12-17-30Page 302 1151-199, 201-299, 301-399, 401-499, 1Aug 01/05 1 1 1CES 1
Rain-Repellent Fluid Gage
Figure 301/TASK 12-17-30-991-001
R 1EFF : 001-049, 051-052, 054-056, 058-059, 1 12-17-30Page 303 1061-099, 101-101, 103-149, 151-199, 201-299, 1Aug 01/05 1301-399, 401-499,1 1CES 1
SCHEDULED SERVICING - DESCRIPTION AND OPERATION
_______________________________________________
1. General
_______ This section provides instructions related to the servicing operations, for which a frequency is specified. The different operations are classified as follows:
-CLEANING (Ref. ATA 12-21),
-LUBRICATION (Ref. ATA 12-22),
-DRAINAGE (Ref. ATA 12-24),
-USE OF MANUAL (MAGNETIC) FUEL QUANTITY INDICATORS (Ref. ATA 12-28).
CLEANING - DESCRIPTION AND OPERATION
____________________________________
1. General
_______ This section covers the procedures to be applied for the aircraft external and internal cleaning.
EXTERNAL CLEANING - SERVICING
_____________________________
TASK 12-21-11-615-001
External Cleaning
WARNING : USE SOLVENTS/CLEANING AGENTS, SEALANTS AND OTHER SPECIAL MATERIALS
_______
ONLY WITH A GOOD SUPPLY OF AIR.
OBEY THE MANUFACTURERS INSTRUCTIONS.
PUT ON PROTECTIVE CLOTHING.
DO NOT GET THEM IN YOUR MOUTH.
DO NOT SMOKE.
DO NOT BREATHE THE GAS.
THESE MATERIALS ARE POISONOUS, FLAMMABLE AND SKIN IRRITANT.
GET MEDICAL HELP IF YOUR SKIN OR EYES BECOME IRRITATED.
WARNING : WEAR AND ATTACH A SAFETY HARNESS WHEN YOU WORK ON HIGH SECTIONS. A
_______
FALL CAN INJURE OR KILL YOU.
WARNING : OPERATE THE DITCHING SWITCH INSTALLED ON THE PANEL 25VU AFTER THE
_______ EXTERNAL CLEANING OF THE AIRCRAFT. THIS WILL OPEN THE OUTFLOW VALVE, THE SKIN INLET VALVE AND THE SKIN OUTLET VALVE. THESE VALVES WHEN OPEN PREVENT OVERPRESSURES IN THE CABIN WHICH COULD CAUSE THE DOOR TO OPEN SUDDENLY. THE DOOR CAN BE DANGEROUS IF IT OPENS SUDDENLY.
CAUTION : USE THE CLEANING PRODUCTS CAREFULLY. THEY CAN CAUSE DAMAGE TO THE
_______
PLEXIGLAS. YOU MUST NOT USE THEM ON THE WINDOWS.
CAUTION : DO NOT POINT HIGH-PRESSURE JETS:
_______
-AT EQUIPMENT SUCH AS GEAR BOX SEALS, STEADY BEARINGS, ROTARY
ACTUATORS AND UNIVERSAL JOINTS, R - AT ELECTRICAL COMPONENTS SUCH AS HARNESSES, PROXIMITY SENSORS AND R CONNECTORS.
THE IMPACT PRESSURE OF THE JETS MUST NOT BE MORE THAN 5 PSI (0.35
BAR). FOR FAIRINGS, THE IMPACT PRESSURE OF THE JETS MUST NOT BE MORE
THAN 1.5 PSI (0.1 BAR).
HIGH PRESSURE JETS CAN PUSH LIQUIDS INTO BEARINGS, JOINTS, BRAKES,
ELECTRICAL CONNECTORS AND OTHER SEALED COMPONENTS. LIQUIDS THAT GET
INTO THESE AREAS CAN CAUSE CORROSION, FREEZE DURING AIRCRAFT FLIGHT,
REMOVE NECESSARY LUBRICANTS OR START INCORRECT ELECTRICAL FUNCTIONS.
1. Reason for the Job
__________________
Self Explanatory
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific adhesive tape
No specific polyethylene film
No specific rubber boots
No specific rubber gloves
No specific sponge
No specific spraying equipment
No specific waterproof overalls with hood
No specific wheel chocks
No specific mobile equipment 12 m (39 ft. 4 in.)
HIX6002 2 HALF PLUG, RIGHT-THRUST REVERSER
HIX6003 2 HALF PLUG, LEFT-THRUST REVERSER
RSE1132 2 COVER - COMMON NOZZLE
98A10001005000 3 COVER - SLIP-ON PITOT PROBE
98A10001013000 2 COVER - SLIP-ON, TOTAL TEMPERATURE SENSOR
98A10001500000 3 COVER - SLIP-ON, ANGLE OF ATTACK SENSOR
98D10003002000 2 COVER - INLET COWL ENGINE
98D10003003000 3 COVER - SLIP-ON, AOA
98D10007512000 1 COVER - EXHAUST DUCT, APU
98D10007513000 1 COVER - OILCOOLER OUTLET, APU
98D10103500001 2 COVER-STATIC PROBE
R 98D10103501000 2 COVER - ICE DETECTION PROBE 中國航空網 www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM SERVICING 1(118)
