F 『 EEFF : ALL E Page 60678-31-41
E E Feb 01/98 E E ECES E TASK 78-31-41-210-042
F 『
E C F M E
E E
E 56-5B E
E E
General Visual Inspection of Actuator Rod End Attachments
1. Reason for the Job
__________________
Refer to the MPD TASK: 783100-C5
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific warning notice No specific access platform 1 m (3 ft. 3 in.) HIX3005 1 SAFETY SLEEVE - PIVOTING DOOR ACTUATOR
B. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
71-13-00-010-040 Opening of the Fan Cowl Doors 71-13-00-410-040 Closing of the Fan Cowl Doors 78-30-00-081-041 Make the Thrust Reverser Serviceable after
Maintenance 78-30-00-481-041 Make the Thrust Reverser Unserviceable for Maintenance 78-31-41-000-001 Removal of the Blocker Door Hydraulic Actuator (3001KM1,3001KM2,3001KM3, 3001KM4) 78-31-41-400-001 Installation of the Blocker Door Hydraulic Actuator (3001KM1,3001KM2,3001KM3, 3001KM4) 78-32-41-080-001 Removal of the Safety Sleeve from Blocker Door Actuator 78-32-41-480-001 Installation of the Safety Sleeve on Blocker Door
Actuator 78-32-41-860-001 Manual Deployment of the Blocker Door 78-32-41-860-002 Manual Stowing of the Blocker Door 78-31-41-991-306 Fig. 601 78-31-41-991-307 Fig. 602
F 『 EEFF : ALL E Page 60778-31-41
E E Feb 01/98 E E ECES E E 56-5B E
F 『
E C F M E
E E
E E
3. Job Set-up
__________
Subtask 78-31-41-941-054
A. Safety Precautions
(1) On the center pedestal, on the ENG panel 115VU:
(a) Put a warning notice to tell persons not to start the engine.
(2) Make sure that the engine 1(2) shutdown occurred not less than 5 minutes before you do this procedure.
(3) On the overhead maintenance panel 50VU:
(a) Make sure that the ON legend of the ENG/FADEC GND PWR/1(2) pushbutton switch is off.
(b) Put a warning notice to tell persons not to energize the FADEC 1(2).
Subtask 78-31-41-010-055
B. Get Access
(1) Open the fan cowl doors: (Ref. TASK 71-13-00-010-040)
FOR 1000EM1
437AL, 438AR
FOR 1000EM2
447AL, 448AR
(2) Put the access platform in position .
Subtask 78-31-41-040-053
C. Make the thrust reverser unserviceable (Ref. TASK 78-30-00-481-041).
Subtask 78-31-41-860-051
D. Open the blocker door manually (Ref. TASK 78-32-41-860-001).
Subtask 78-31-41-480-050
E. Install the SAFETY SLEEVE - PIVOTING DOOR ACTUATOR (HIX3005) on blocker door (Ref. TASK 78-32-41-480-001).
F 『 EEFF : ALL E Page 60878-31-41
E E Feb 01/98 E E ECES E 4. Procedure
F 『
E C F M E
E E
E 56-5B E
E E
_________
(Ref. Fig. 601/TASK 78-31-41-991-306, 602/TASK 78-31-41-991-307)
Subtask 78-31-41-210-051
A. Do a visual inspection of the clevis and the related hardware as follows :
-------------------------------------------------------------------------------INSPECT/CHECK MAXIMUM REMARKS SERVICEABLE LIMITS -------------------------------------------------------------------------------
1. Examine the clevis and the related hardware for:
A. Damage No damage permitted If you find damage, replace the defective part (Ref. TASK 78-31-41-000-001) and (Ref. TASK 78-31-41-400-001)
B. Missing None permitted If you find missing, replace the defective part (Ref. TASK 78-31-41-000-001) and (Ref. TASK 78-31-41-000-001)
5. Close-up
________
Subtask 78-31-41-080-050
A. Remove the safety sleeve (HIX3005) from the blocker door actuator
(Ref. TASK 78-32-41-080-001).
Subtask 78-31-41-860-054
B. Close the blocker doors.
CAUTION : BLOCKER DOOR LATCH MUST BE OPENED WHEN YOU CLOSE THE BLOCKER
_______
DOOR OR DAMAGE CAN OCCUR.
(1) Move the blocker doors to the closed position manually (Ref. TASK 78-32-41-860-002).
F 『 EEFF : ALL E Page 60978-31-41
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM EXHAUST 1(73)
