21-22-02
 ALL  ú ú 07 Page 403 ú Oct 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 S 024-020
 (3) Remove the stowage box (AMM 35-11-18/401).
 D. Procedure
 S 024-005
 (1)  Remove the flight deck shoulder air outlet valve.
 (a)  
Disconnect the control cable from the valve assembly.

 (b)  
Remove two straps from each end of the valve.

 (c)  
Pull the sleeve off the valve.

 (d)  
Remove the four screws and washers on the clamps that hold the valve.

 (e)  
Remove the clamps.

 (f)  
Remove the valve.

 TASK 21-22-02-004-006
 3. Flight Deck Shoulder Air Outlet Valve Installation (Fig. 401)
__________________________________________________
 A. References
 (1)  
AIPC 21-22-01 Fig. 1

 (2)  
AMM 25-11-01/401, Pilots' seats

 (3)  
AMM 35-11-18/401, Mask, Demand Regulator, and Stowage Box

 B. Access
 (1)  Location Zone
 221 Control Cabin, LH
 222 Control Cabin, RH

 C. Install the Flight Deck Shoulder Air Outlet Valve
 S 024-007
 (1)  
Install the flight deck shoulder air outlet valve.

 (a)  
Connect the control cable to the valve.

 (b)  
Put the sleeve over the valve.

 (c)  
Install the ducts and the straps on each end of the valve.

 (d)  
Install the clamps and tighten the screws.

 (2)  
Install the stowage box (AMM 35-11-18/401).

 S 424-021
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 21-22-02
 ALL  ú ú 07 Page 404 ú Oct 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 S 424-016
 (3)  Install the captain's and/or first officer's seats (AMM 25-11-01/401).
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 21-22-02
 ALL  ú ú 07 Page 405 ú Oct 15/98
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 MAIN AND UPPER DECK CONDITIONED AIR DISTRIBUTION - ADJUSTMENT/TEST
__________________________________________________________________
 1.  General
_______
 A.  The 5 main deck fire shutoff valves and the pack dump valves (SMACCS valves) will close when the Main Deck Cargo Fire Arm switch is set to the ARMED position.
 B.  This procedure has two tasks to do a test of the main deck fire shutoff valves and the pack dump valves.
 (1)  
The first task is the usual way to do a test of the valves. This method uses the ECS Freighter card to cycle the valves.

 (2)  
The alternate task should be used when the ECS freighter card is inoperative and the first test can not be done.

 TASK 21-23-00-705-008
 2.  Main Deck Shutoff Valves and Pack Dump Valves - Operational Test
________________________________________________________________
 A.  References
 (1)  AMM 24-22-00/201, Manual Control
 B.  Access
 (1)  Location Zone
 221 Control Cabin, LH
 222 Control Cabin, RH

 C.  Procedure
 S 865-007
 (1)  
Supply electrical power (AMM 24-22-00/201).

 S 865-001

 (2)  
Put the three air conditioning pack switches on the overhead P5 panel to OFF.

 (3)  
Push and hold the FIRE/OVHT TEST switch on the P5 panel.

 S 865-002
 NOTE: You must hold the switch down for approximately 15 seconds to
____ start the automatic test of the valves.
 S 715-003
 (4)  
Make sure that after approximately 15 seconds the EICAS message VLV TEST IN PROG shows on the EICAS display.

 S 715-004

 (5)  
Make sure that the EICAS message VALVE TEST PASS shows on the EICAS display approximately 2 minutes after you start the test.
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 空調 AIR CONDITIONING 1(28)