R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 315 1401-499, 1Aug 01/05 1 1 1CES 1

 B. Consumable Materials

 -------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 04-004  USA MIL-PRF-23827 TYPE I SYNTH.ESTER BASED GREASE HIGH PRESSURE (Ref. 20-31-00)
 Material No. 04-024  AIB AIMS 09-06-001 SYNTHETIC GREASE FOR FLAP & SLAT MECHANISM (Ref. 20-31-00)
 Material No. 19-003  USA AMS 3819 LINT-FREE COTTON CLOTH (Ref. 20-31-00)
 C. Referenced Information
 -------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
27-50-00-866-008 Extension of the Flaps on the Ground 27-50-00-866-009 Retraction of the Flaps on the Ground SIL 12-008 (for corrective action) 12-22-27-991-006 Fig. 303
 3. Job Set-up
__________
 Subtask 12-22-27-941-060
 A. Safety Precautions
 (1) Put the safety barriers in position.
 Subtask 12-22-27-866-060
 B. Aircraft Maintenance Configuration
 (1)
 Extend the flaps fully (Ref. TASK 27-50-00-866-008).

 (2)
 On panel 114VU, make sure that the LOCKING TOOL - FLAP/SLAT CONTROL LEVER is installed on the flap/slat control lever.

 (3)
 Put a warning notice on the flap/slat control lever (panel 114VU) to tell persons not to operate the flap system.

 (4)
 Put the access platform in position under the applicable flap track.

R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 316 1401-499, 1Aug 01/05 1 1 1CES 1

 Subtask 12-22-27-865-072

 C. Open, safety and tag this(these) circuit breaker(s):
 -------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------49VU FLIGHT CONTROLS/FLP/CTL AND MONG/SYS1 6CV B07 121VU FLIGHT CONTROLS/FLP/CTL AND/MONG/SYS2 8CV Q21
 4. Procedure
_________
 (Ref. Fig. 303/TASK 12-22-27-991-006)
 Subtask 12-22-27-640-060
 A. Lubricate the Flap Track Carriage Rollers and No.1 Track Lever Arm
 CAUTION : BE CAREFUL WHEN YOU DO MAINTENANCE TASKS ON THE WING TRAILING
_______
 EDGE:

 -
DO NOT CAUSE DAMAGE TO THE ELECTRICAL CABLE RACEWAYS.

 -
DO NOT CAUSE DAMAGE TO THE ELECTRICAL CABLE INSTALLATIONS.

 -MAKE SURE THAT THE ELECTRICAL CABLES ARE INSTALLED CORRECTLY. INCORRECT INSTALLATION CAN CAUSE DAMAGE.
 NOTE : When you do a maintenance task that uses grease, refer to the SIL
____
 (Ref. SIL 12-008).

 NOTE : Make sure that the greaser ball of each greaser has sealed
____
 correctly after lubrication.

 (1)
 Clean the greasers of the flap track carriage rollers with a clean MISCELLANEOUS (Material No. 19-003).

 (2)
 Lubricate the flap track carriage rollers with COMMON GREASE (Material No. 04-004) or COMMON GREASE (Material No. 04-024) through the greasers until new grease comes out.

 (3)
 Remove the unwanted grease from around the greasers with a clean MISCELLANEOUS (Material No. 19-003).

 (4)
 Clean the greasers of the No.1 track lever arm with a clean MISCELLANEOUS (Material No. 19-003).

 (5)
 Lubricate the No.1 track lever arm with COMMON GREASE (Material No. 04-004) or COMMON GREASE (Material No. 04-024) through the greasers until new grease comes out.

R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 317 1401-499, 1Aug 01/05 1 1 1CES 1

 Flap Track Carriage Rollers and Drive Lever Arm - Lubrication Points Figure 303/TASK 12-22-27-991-006- 12 (SHEET 1)
R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 318 1401-499, 1Aug 01/05 1 1 1CES 1

 Flap Track Carriage Rollers and Drive Lever Arm - Lubrication Points Figure 303/TASK 12-22-27-991-006- 22 (SHEET 2)
R 1EFF : 062-099, 104-149, 151-199, 204-299, 1 12-22-27Page 319 1401-499, 1Aug 01/05 1 1 1CES 1

 (6) Remove the unwanted grease from around the greasers of the No.1 track lever arm with a clean MISCELLANEOUS (Material No. 19-003). ________
5. Close-up
 Subtask 12-22-27-865-073
 A. Remove the safety clip(s) and the tag(s) and close this(these) circuit breaker(s): 6CV, 8CV.
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM SERVICING 2(5)