- replace the Spoiler Servo Control in relation to the wrong indication. SERVO CTL-SPLR1, L G (31CE1), SERVO CTL-SPLR1, R G (31CE2), for spoiler 1 SERVO CTL-SPLR2, L Y (31CE3), SERVO CTL-SPLR2, R Y (31CE4), for spoiler 2 SERVO CTL-SPLR3, L B (31CE5), SERVO CTL-SPLR3, R B (31CE6), for spoiler 3 SERVO CTL-SPLR4, L Y (31CE7), SERVO CTL-SPLR4, R Y (31CE8) for spoiler 4 SERVO CTL-SPLR5, L G (31CE9), SERVO CTL-SPLR5, R G (31CE10) for spoiler 5 (Ref. AMM TASK 27-64-51-000-004) and (Ref. AMM TASK 27-64-51-400-004).
(2) If the fault continues:
- do a check and repair the wiring of the LVDT POS Signal from the spoiler servocontrol to the SEC COM and MON parts (Ref. ASM 27-94/02), (Ref. ASM 27-94/04).
5. Close-up
________
A. Do the test given in Para 3.
SLATS ELECTRICAL CONTROL AND MONITORING - FAULT ISOLATION PROCEDURES
____________________________________________________________________
TASK 27-81-00-810-801
SFCC - Slat PCU Valveblock Fault
WARNING : PUT THE SAFETY DEVICES AND THE WARNING NOTICES IN POSITION BEFORE YOU
_______ START A TASK ON OR NEAR:
- THE FLIGHT CONTROLS
- THE FLIGHT CONTROL SURFACES
- THE LANDING GEAR AND THE RELATED DOORS
- COMPONENTS THAT MOVE.
WARNING : MAKE SURE THAT THE TRAVEL RANGES OF THE FLIGHT CONTROL SURFACES ARE
_______ CLEAR BEFORE YOU PRESSURIZE/DEPRESSURIZE A HYDRAULIC SYSTEM.
WARNING : MAKE SURE THAT THE GROUND SAFETY-LOCKS ARE IN POSITION ON THE LANDING
_______ GEAR.
1. Possible Causes
_______________
- SFCC-1 (21CV)
- SFCC-2 (22CV)
- VALVE BLOCK SLAT 1 (25CV)
- VALVE BLOCK SLAT 2 (26CV)
- solenoid valve
- valve block filters
- aircraft wiring
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific 45VDC Isolation Tester No specific 1 MEGOHMMETER 100 MOHMS - MEASURING VOLTAGE 45VDC No specific 1 MULTIMETER - STANDARD
「一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一1 EFF : ALL ∞∞27-81-00∞∞∞∞∞∞∞∞∞∞Page 201
May 01/05R
CES
B. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
AMM 27-51-34-000-001 Removal of the SFCC (21CV,22CV) AMM 27-51-34-400-001 Installation of the SFCC (21CV,22CV) AMM 27-80-00-866-004 Extending the Slats on the Ground AMM 27-80-00-866-005 Retracting the Slats on the Ground AMM 27-84-53-000-001 Removal of the Valve Blocks 25CV, 26CV of the Power
Control Unit (Slat) AMM 27-84-53-000-002 Removal of the Solenoid Valves of the Power Control
Unit (Slat) AMM 27-84-53-000-003 Removal of the Filters of the Valve Blocks AMM 27-84-53-400-001 Installation of the Valve Blocks 25CV, 26CV of the
Power Control Unit (Slat) AMM 27-84-53-400-002 Installation of the Solenoid Valves of the Power Control Unit (Slat)
AMM 27-84-53-400-003 Installation of the Filters of the Valve Blocks R AMM 31-32-00-860-006 Procedure to Get Access to the SYSTEM REPORT/TEST R F/CTL Page
ASM 27-81/02
ASM 27-81/03
3. Fault Confirmation
__________________
A. Test
(1) Make sure that the Post Flight Report does not show any hydraulic system faults.
(2) Move the slats (Ref. AMM TASK 27-80-00-866-004) and (Ref. AMM TASK 27-80-00-866-005).
R (a) Examine the SFCC, SLT ON GROUND FAULTS page for a PCU valve block R message.
R (3) If a valve block message is shown, or the A/C has had this fault R before, do the fault isolation procedure.
4. Fault Isolation
_______________
A. Procedure. R CAUTION: DO NOT SHORT CIRCUIT THE WIRING TO THE SOLENOID VALVES. R DAMAGE TO THE SFCC CAN OCCUR
「一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一一1 EFF : ALL ∞∞27-81-00∞∞∞∞∞∞∞∞∞∞Page 202
Nov 01/00 CES
(1) Do a check of the circuit resistance and the circuit isolation of the extend and retract solenoids on each slat system PCU valve block (25CV; 26CV) as follows:
(a) Get access to the electrical connector on each valve block (Ref. AMM TASK 27-84-53-000-001).
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320 Trouble Shooting Manual 排故手冊 飛行操縱 2(55)
