C. Lamp Replacement
S 012-010
(1) Remove the lens.
(a)
Remove the screws from the lens.
(b)
Carefully pull the lens from the fuselage.
(c)
Remove the gasket.
S 962-004
(2) Replace the lamp.
(a) Remove the lamp.
NOTE: For a forward overwing light, remove the screws which
____ hold the lamp retainer.
(b)
Clean the overwing light assembly with a clean dry cloth.
(c)
Install the new lamp.
NOTE: For a forward overwing light, install the screws in the
____
retainer.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
33-51-22
ALL ú ú 01 Page 201 ú Nov 15/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 737-300/400/500MAINTENANCE MANUAL EXIT LIGHTS OVERWING FORWARD SEE A
EXIT LIGHTS AFT OVERWING BSEE
HATCHES EMERGENCY EXIT
(2 LOCATIONS) LAMP REFLECTORS A LAMP RETAINER (6 LOCATIONS) SCREWS LENS ASSEMBLY
REFLECTOR LAMP
LENS ASSEMBLY
(4 LOCATIONS) SCREWS
B Figure 201 Emergency Exit Overwing Lights
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
33-51-22
ALL ú ú 02 Page 202 ú Mar 15/91
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
D. Lamp Test
S 722-005
(1) At the overhead panel, P5, or the attendant's panel, set the emergency lights switch to the on position.
NOTE: Keep a record of the time that the emergency lights are on.
____
(a) In the least possible time, make sure the new lamp comes on correctly.
S 862-012
(2) Quickly set the emergency lights switch to the usual position.
(a) Make sure the emergency lights go off.
S 412-006
(3)
Install the lens with a gasket and the screws.
S 862-011
(4)
If it is necessary, charge the batteries for the emergency lights (AMM 33-51-51/201).
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
33-51-22
ALL ú ú 01 Page 203 ú Nov 15/93
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 737-300/400/500MAINTENANCE MANUAL
EMERGENCY LIGHTS CONTROL PANELS - REMOVAL/INSTALLATION
______________________________________________________
1. General
_______
A. This procedure contains these tasks for a emergency lights control panel:
(1)
The removal of the pilot's control panel from the overhead panel, P5.
(2)
The installation of the pilot's control panel.
(3)
The removal of the aft attendant's panel, P14.
(4)
The installation of the aft attendant's panel.
TASK 33-51-31-004-001
2. Pilot's Control Panel Removal
_____________________________
A. References
(1) WDM 33-51-11
B. Access
(1) Location Zone
101 Control Cabin - Left
102 Control Cabin - Right
C. Procedure
S 024-002
(1) Remove the pilot's control panel from the overhead panel, P5.
NOTE: Keep a record of the time that the emergency lights are on.
____
(a)
Remove the fasteners and lower the pilot's control panel.
(b)
Disconnect the electrical connector at the rear of the pilot's control panel.
NOTE: The emergency lights will come on automatically.
____
(c) Quickly ground pins 1 and 6 of electrical connector D4048J with jumper wires (WDM 33-51-11).
NOTE: This temporary change to the circuit will keep the
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 燈 LIGHTS(104)
