Consumable Materials
(1)
G00033 Cheesecloth, BMS 15-5
(2)
Solvent
NOTE: You can use one of these solvents:
____
(a)
B00111 Freon TF
(b)
B00093 Tetrachloroethylene O-T-236
(c)
B00090 1.1.1 Trichloroethane MIL-T-81533A
(3) Tape - Glass Cloth, Fire-Resistant
NOTE: You can use one of these tapes:
____
(a) G00348 Permacel P-621
(b)
G01355 3M YR-367 FRAccess
(1)
Location Zone 100 Lower Half of Fuselage
Procedure
S 348-002
(1) Remove the loose or damaged tape and discard it.
NOTE:____The loose or damaged tape must not be used again. The tape will not bond correctly to the cargo lining if you use it again.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
25-52-01
ALL ú ú 01A Page 803 ú Jun 10/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
S 118-060
(2) Clean the surface of the cargo lining with a cheesecloth or wiper that is moist with the solvent.
NOTE: A clean surface is necessary for the tape to bond correctly
____
to the cargo lining.
S 348-003
(3) Install the new tape on the cargo lining.
NOTE: The tape must extend equally around the top of the fasteners,
____ joints, and edges on the cargo lining.
S 348-004
(4) Make sure the tape bonds fully to the cargo lining.
NOTE:____There must be no air bubbles below the tape. The tape must be flat on the surface of the cargo lining.
TASK 25-52-01-308-062
3. Rigid Cargo Liner Permanent Repairs___________________________________
A. General
(1)
The permanent repairs contain three alternatives. It is only necessary to use one of the three alternatives.
(2)
Use the applicable consumable materials that are necessary for the repair procedure you use.
WARNING: OBEY THE INSTRUCTIONS FROM THE INDUSTRIAL HYGIENE, FIRE, AND
_______ SAFETY ORGANIZATIONS FOR THE NECESSARY PROCEDURES AND EQUIPMENT WHEN YOU USE ADHESIVES AND SOLVENTS. DO NOT GET THE ADHESIVES AND SOLVENTS IN YOUR MOUTH OR EYES, OR ON YOUR SKIN. DO NOT BREATHE THE FUMES FROM THE ADHESIVES AND SOLVENTS. USE A PROTECTIVE SPLASH GOGGLE, GLOVES, AND A RESPIRATOR (IN CONFINED AREAS) WHEN YOU USE THE ADHESIVES AND SOLVENTS. KEEP THE ADHESIVES AND SOLVENTS AWAY FROM ALL SOURCES OF IGNITION (HEAT, FLAME, AND SPARKS). THE ADHESIVES AND SOLVENTS YOU USE ARE POISONOUS AND FLAMMABLE. IF YOU DO NOT USE THE CORRECT PROCEDURES AND EQUIPMENT, INJURY TO PERSONS OR DAMAGE TO THE EQUIPMENT CAN OCCUR.
(3) This procedure uses adhesives and solvents to repair the cargo lining. There must be sufficient air flow in the area where you use the adhesives and solvents. You must not get the adhesives and solvents in your mouth or eyes, or on your skin.
B. Equipment
(1) Knife or scissors (commercially available)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
25-52-01
ALL ú ú 01A Page 804 ú Jun 10/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL
C. Consumable Materials
(1)
Abrasive paper (80-grit) - commercially available
(2)
B00065 Alcohol - denatured
(3)
Use the materials that follow for the bonded patch with screws repair procedure:
(a)
A00016 Adhesive - Film, BMS 5-91, Type I, II, or III
(b)
Screws - Steel Sheet Metal, 0.164 inch diameter
(U.S. size No. 8) x 3/16 inch long (commercially available)
(c)
G02163 Liner - Glass Fiber - Reinforced Phenolic Laminate, BMS 8-223 Grade B
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 EQUIPMENT/FURNISHINGS 1(120)
