(2)  
AMM 53-52-01/201, Nose Radome

 (3)  
AIPC 34-43-03 Fig. 1

 B. Access
 (1)  Location Zone
 111 Radome

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 34-43-03
 ALL  ú ú 06 Page 408 ú Feb 18/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 C. Procedure
 S 864-094
 (1)  Make sure these circuit breakers are open with DO-NOT-CLOSE tags attached:
 (a)  P7 Overhead Circuit Breaker Panel
 1) 7C7, WXR L RT
 2) 7C19, WXR R RT

 S 434-075
 (2)  Remove dust caps from the airplane and antenna electrical connectors and waveguide flange.
 NOTE: Replace the gasket if it is defective.
____
 S 424-047
 (3)  Install the weather radar antenna:
 WARNING: DURING AN ANTENNA INSTALLATION, USE TWO PERSONS AND A
_______ SAFELY INSTALLED WORKSTAND. THE ANTENNA WEIGHS APPROXIMATELY 25 POUNDS.
 BE CAREFUL WITH THE ANTENNA DURING INSTALLATION. CAREFULLY INSTALL THE ANTENNA TO PREVENT INJURY TO YOU OR CAUSE DAMAGE TO THE ANTENNA.
 (a)  
Put the antenna on the two top mount bolts and lower the antenna until it is on the top mount bolts.

 (b)  
Put the two bottom bolts and washers through the antenna and the mount.

 (c)  
Tighten all four mount bolts to 220-240 pound-inches.

 (d)  
Attach the quick disconnect between the waveguide Section 1 and the antenna waveguide.

 (e)  
Connect the electrical connector DB143A to the antenna connector J1.

 (f)  
Connect the electrical connector DB143B to the antenna connector J2.

 S 864-048
 (4) Remove the DO-NOT-CLOSE tags and close these circuit breakers:
 (a)  P7 Overhead Circuit Breaker Panel
 1) 7C7, WXR L RT
 2) 7C19, WXR R RT

 S 714-049
 (5)  Do the weather radar operational test or the ground test
 (AMM 34-43-00/501).

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 34-43-03
 ALL  ú ú 04 Page 409 ú Feb 18/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 S 734-050
 (6)  
Do the Antenna Tilt Tests in the Weather Radar System - Adjustment Test (AMM 34-43-00/501).

 S 734-051

 (7)  
Do the Stabilization Test in the Weather Radar System -Adjustment/Test (AMM 34-43-00/501).

 S 864-076

 (8)  
If electrical power is not necessary,
 Remove electrical power (AMM 24-22-00/201).

 S 414-100

 (9)  
Close the nose radome (AMM 53-52-01/201).

 TASK 34-43-03-404-028
 6.  Weather Radar Antenna Planar Array Installation (Fig. 402)_______________________________________________
 A. References
 (1)  
AMM 24-22-00/201, Manual Control

 (2)  
AMM 34-43-00/501, Weather Radar System

 (3)  
AMM 53-52-01/201, Nose Radome

 (4)  
AIPC 34-43-03 Fig. 1

 B. Access
 (1)  Location Zone
 111 Radome

 C. Procedure
 S 864-073
 (1)  Make sure these circuit breakers are open with DO-NOT-CLOSE tags attached:
 (a)  P7 Overhead Circuit Breaker Panel
 1) 7C7, WXR L RT
 2) 7C19, WXR R RT

 S 434-077
 (2)  
Remove dust caps from the waveguide flanges on the antenna drive assembly and the planar array.

 (3)  
Install the planar array:

 S 424-052
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 34-43-03
 ALL  ú ú 04 Page 410 ú Feb 18/02
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 導航 NAVIGATION 2(133)