C. Expendable Parts -------------------------------------------------------------------------------
FIG.ITEM --------- |DESIGNATION ---------------------------------------- |IPC-CSN------------------------------
3 packing 29-11-06 01 -080
D. Referenced Information
------------------REFERENCE -------------------------------DESIGNATION ------------------------------
-------------------------------------------------------------------------------
12-12-29-611-001 Fill the Hydraulic Fluid Reservoir with a Hand Pump 29-11-00-710-001 Operational Test of the Green Hydraulic System 29-14-00-614-001 Depressurization of the Hydraulic Reservoirs 29-23-00-864-001 Depressurize the Green and Yellow Hydraulic Systems
after Operation of the PTU 71-13-00-410-040 Closing of the Fan Cowl Doors 29-11-37-991-001 Fig. 401
3. Job Set-up
__________
Subtask 29-11-37-860-051
A. Aircraft Maintenance Configuration
(1)
Make sure that the Green hydraulic system is depressurized (Ref. TASK 29-23-00-864-001).
(2)
Make sure that the Green hydraulic reservoir is depressurized (Ref. TASK 29-14-00-614-001).
(3)
Make sure that the warning notice(s) is (are) in position to tell persons not to pressurize the Green hydraulic system: - on the ground service panel 197CB.
(4)
Make sure that the warning notice(s) is (are) in position on the access door 195BB to tell persons not to pressurize the Green hydraulic reservoir.
(5)
Make sure that an access platform is in position at the engine 1(2).
(6)
Make sure that the fan-cowl door is open.
1EFF : ALL 1 29-11-37Page 406 1 1 Feb 01/05R 1 1 1CES 1
Subtask 29-11-37-941-051
B. Safety Precautions
(1)
On the center pedestal, on the ENG panel 115VU:
-make sure that the warning notice(s) is (are) in position to tell persons not to start the engine.
(2)
Make sure that the engine 1(2) shutdown occurred not less than 5 minutes before you do this procedure.
(3)
Make sure that the warning notice(s) is (are) in position to tell persons not to pressurize the Green hydraulic system:
-in the cockpit, on the HYD overhead panel 40VU.
(4)
On the overhead maintenance panel 50VU:
-make sure that the ON legend of the ENG/FADEC GND PWR/1(2) pushbutton switch is off.
(5)
Make sure that the warning notice(s) is (are) in position to tell persons not to energize the FADEC 1(2).
(6)
Make sure that a container is below the hydraulic tube connection to the switch (25) to collect the remaining fluid.
4. Procedure
_________
(Ref. Fig. 401/TASK 29-11-37-991-001) Subtask 29-11-37-420-050
A. Installation of the Green Engine 1 Pump Case Drain Check valve (1041GM)
(1)
Apply HYDRAULIC FLUIDS (Material No. 02-003) to the new packing (3).
(2)
Install the packing (3) on the check valve (1).
(3)
Remove the blanking plug from the panel (4).
(4)
Install the check valve (1) on the panel (4).
(5)
TORQUE the check valve (1) to between 2.82 and 5.87 m.daN (20.79 and
43.28 lbf.ft).
(6)
Remove the blanking plug from the disconnected hose (2).
(7)
Connect the hose (2) to the check valve (1).
R (8) TORQUE the coupling nut to between 2.43 and 2.77 m.daN (17.92 and 20.42 lbf.ft).
Subtask 29-11-37-710-050
B. Test
(1) Do an operational test of the Green hydraulic system (Ref. TASK 29-11-00-710-001)
(2) During the dry motoring, make sure that there are no leaks from the check valve.
(3) Make sure that the level of the hydraulic fluid in the Green reservoir is correct. If necessary, fill the reservoir (Ref. TASK 12-12-29-611-001).
5. Close-up________
Subtask 29-11-37-942-050
A. Remove the Safety Precautions
R (1) Remove the warning notice(s).
R (2) Remove the container.
(3) Make sure that the work area is clean and clear of tool(s) and other items.
Subtask 29-11-37-410-050
B. Close access
R (1) Remove the access platform(s).
R R (2) Close the left fan-cowl door 437AL (Ref. TASK 71-13-00-410-040).
SELF SEALING COUPLING - ENGINE 1 PUMP SUCTION - REMOVAL/INSTALLATION 中國航空網 www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM HYDRAULIC POWER 液壓2(52)
