12-13-21
ú CONFIG ú 01 Page 306 ú Jul 12/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
S 493-023-001
(3) Connect the coupling to the case pressure-fill valve.
S 823-024-001
CAUTION: DO NOT USE MORE THAN 40 PSIG TO FILL THE GENERATOR DRIVE WITH
_______ OIL. TOO MUCH PRESSURE CAN CAUSE DAMAGE TO THE GENERATOR DRIVE.
(4) Set the pressure from the service cart to 5-40 psig.
S 613-025-001
CAUTION:_______DO NOT PUT TOO MUCH OIL INTO THE GENERATOR DRIVE. TOO MUCH OIL WILL CAUSE THE GENERATOR DRIVE TO BECOME TOO HOT AND CAUSE DAMAGE TO THE GENERATOR DRIVE.
IF YOU MOTOR THE ENGINE, DO NOT ADD OIL AGAIN. AFTER YOU MOTOR THE ENGINE, SOME OF THE OIL WILL STAY IN THE CSD RESERVOIR. THIS MAKES THE SIGHT GLASS SHOW AN OIL LEVEL THAT IS TOO LOW AND NOT ACCURATE. YOU MUST OPERATE THE ENGINE AT AN IDLE TO GET AN OIL LEVEL INDICATION THAT IS ACCURATE.
(5) Fill the CSD until the oil level increases to the bottom of the applicable range on the sight glass.
NOTE: The oil level will increase when the CSD becomes warm.
____
(a) Stop for five minutes.
NOTE: The time will let the oil level become stable.
____
S 213-026-001
(6)
Look at the oil level in the sight glass on the CSD.
(a)
If the oil level is below the bottom of the applicable range, add oil to the CSD.
(b)
If the oil level is above the top of the applicable range, drain some of the oil from the CSD (Ref "Drain the Oil From the CSD" task).
(7)
Remove the coupling from the case pressure-fill valve.
S 093-027-001
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. CONSTANT SPEED DRIVES ú
12-13-21
ú CONFIG ú 01 Page 307 ú Jul 15/92
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
S 433-028-001
(8) Install the cap on the case pressure-fill valve.
S 163-029-001
CAUTION: IMMEDIATELY REMOVE ALL OF THE OIL THAT FALLS ON THE ENGINE.
_______ THE OIL CAN CAUSE DAMAGE TO THE PAINT AND THE RUBBER COMPONENTS ON THE ENGINE.
(9)
Clean the engine parts that have oil on them.
S 413-030-001
(10)
Close the left fan cowl on the applicable engine (AMM 71-11-02/201).
TASK 12-13-21-683-039-001
5. Drain the Oil from the Spline Cavity
____________________________________
A. Standard Tools and Equipment
(1) Bucket - to hold 2 gallons of used oil
B. Reference
(1) AMM 71-11-02/201, Fan Cowl Panels
C. Access
(1)
Location Zones
506 Engine 1 - Accessory Gearbox, 8 o'clock
606 Engine 2 - Accessory Gearbox, 8 o'clock
(2)
Access Panels
5746L Left Fan Cowl - Engine 1
5737L Left Fan Cowl - Engine 2
D. Drain the Oil from the Spline Cavity
S 013-040-001
(1)
Open the left fan cowl on the applicable engine if it is not open (AMM 71-11-02/201).
S 873-041-001
(2)
Push the vent valve cap on the top of the CSD to remove the internal pressure.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. CONSTANT SPEED DRIVES ú
12-13-21 中國航空網 www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 SERVICING(38)
