B. Consumable Materials
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 11-001 USA MIL-D-16791 TYPE I
DETERGENT (Ref. 20-31-00)
C. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
24-41-00-861-002 Energize the Aircraft Electrical Circuits from the External Power
24-41-00-862-002 De-energize the Aircraft Electrical Circuits Supplied from the External Power
29-00-00-864-001 49-12-51-000-001 Put the Related Hydraulic System in the Depressurized Configuration before Maintenance ActionRemoval of the FWD LH Tie-Rods and Vibration Isolator
49-12-51-400-001 4035KM (GTCP 36-300)Installation of the FWD LH Tie-Rods and Vibration
49-12-52-000-001 Isolator 4035KM (GTCP 36-300)Removal of the FWD RH Tie-Rods and Vibration Isolator
49-12-52-400-001 4045KM (GTCP 36-300)Installation of the FWD RH Tie-Rods and Vibration
49-12-53-000-001 Isolator 4045KM (GTCP 36-300)Removal of the Aft Tie-Rods and Vibration Isolator
49-12-53-400-001 4055KM (GTCP 36-300)Installation of the Aft Tie-Rods and Vibration
49-12-54-000-001 49-12-54-400-001 52-41-00-010-001 52-41-00-410-001 Isolator 4055KM (GTCP 36-300)Removal of the APU Mount Brackets (4065KM, 4075KM, 4085KM) (GTCP 36-300)Installation of the APU Mount Brackets (4065KM, 4075KM, 4085KM) (GTCP 36-300)Open the APU Doors for AccessClose the APU Doors after Access
**ON A/C 001-003, 051-061, 49-12-00-991-001 Fig. 601 R **ON A/C 062-099, 401-499, 49-12-00-991-001-A Fig. 601A
R **ON A/C 001-003, 051-099, 401-499,
3. Job Set-up
__________
Subtask 49-12-00-860-052
A. Aircraft Maintenance Configuration.
(1)
Put the warning notices on panel 25VU to tell persons not to start the APU.
(2)
Energize the ground service network (Ref. TASK 24-41-00-861-002).
(3)
Make sure that hydraulic systems are depressurized
(Ref. TASK 29-00-00-864-001).
Subtask 49-12-00-865-050
B. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------121VU APU/APU/CTL 2KD L42 121VU APU/ECB/SPLY 1KD L41
Subtask 49-12-00-010-050
C. Get Access
(1)
Put the access platform in position below the APU access doors 315AL and 316AR.
(2)
Open the APU access doors 315AL, 316AR and safety them in the open position (Ref. TASK 52-41-00-010-001).
(3)
Set the LIGHT control switch 11LJ to the ON position.
4. Procedure
_________
Subtask 49-12-00-110-051
A. Cleaning WARNING : DO NOT GET THE FLUID ON YOUR SKIN OR IN YOUR EYES. IF YOU DO:
_______
-FLUSH IT AWAY WITH CLEAN WATER
-GET MEDICAL AID.
(1) Clean the vibration isolators and the tie-rods with a lint free cloth and CLEANING AGENTS (Material No. 11-001).
NOTE : Apply the CLEANING AGENTS (Material No. 11-001) to the cloth
____ and not the cloth to the CLEANING AGENTS (Material No. 11-001). This will prevent the transfer of contamination.
(a)
Carefully clean a small area at a time and remove the CLEANING AGENTS (Material No. 11-001) before it becomes dry. Use a new lint free cloth frequently to make sure dirt is not put back on the surfaces.
(b)
Use a stiff bristle brush to clean any holes, corners and edges.
(2)
When the surfaces are clean, flush with clean water. WARNING : USE THE CORRECT PERSONAL PROTECTION.
_______ COMPRESSED AIR WILL CAUSE LOOSE PARTICLES THAT CAN GET IN YOUR EYES. THE AIRSTREAM CAN CAUSE CUTS, DO NOT POINT IT AT YOUR SKIN. 中國航空網(wǎng) www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護(hù)手冊 AMM 機載輔助動力 AIRBORNE AUXILIARY POWER2(69)
