38-11-31
ALL ú ú 01 Page 403 ú Nov 15/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
(4) S 434-013Install the two bolts and washers that connect the fill valve to the inboard bracket.
(5) S 434-014Install the inboard and outboard stop nuts.
(6) S 024-059Remove the caps from the four lines.
(7) S 434-015Connect the four lines to the fill valve.
(8) S 424-016Connect the shaft to the fill valve as follows: (a) Install the washers and the connect pin. (b) Make sure the fill valve is closed.
(9) S 864-017Fill the water tank (AMM 12-14-00/301).
S 214-019
(10)
Examine all of the fill valve lines and connections for leakage.
S 414-020
(11)
Install the access panel on the aft bulkhead in the aft cargo compartment.
S 084-060
(12)
Remove the placards that you installed when you removed pressure from the water system, if it is necessary.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
38-11-31
ALL ú ú 01 Page 404 ú Nov 15/95
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
FORWARD LAVATORY DRAIN VALVE - REMOVAL/INSTALLATION
___________________________________________________
1. General_______
A. The Forward Lavatory Drain Valve is referred to as the Drain Valve in this procedure.
B. This procedure has two tasks.
(1)
A removal of the drain valve in the forward lavatory.
(2)
An installation of the drain valve.
TASK 38-11-41-004-064
2. Drain Valve Removal (Fig.___________________401)
A. References
(1) AMM 38-41-00/201, Potable Water Sytem - Pressure Release
B. Access
(1) Location Zones
(a) 200 Upper Half of Fuselage
C. Prepare for the Removal
S 014-060
(1) Open this circuit breaker and attach a DO-NOT-CLOSE tag:
(a) Circuit Breaker Panel, P18-3:
1) 18F14 LAVATORY WATER HEATER A
S 864-083
(2)
Do this task: Potable Water System - Pressure Release (AMM 38-41-00/201).
S 014-065
(3)
Get access to the lavatory.
S 014-066
(4)
Open the faucet to release the pressure and to drain some of the water.
S 014-067
(5)
Open the cabinet below the sink to get access to the shutoff valve.
D. Drain Valve Removal
S 024-068
(1)
Loosen the B-nuts for the tube connections at the drain valve [1].
(a) Use a rag to catch the water in the tubes.
(2)
Remove the screws [3] for the bracket [4].
S 024-070
(3)
Remove the handle of the drain valve [1] and then loosen the nut and disconnect the bracket [4].
(4)
Remove the drain valve [1].
S 024-069
S 024-071
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
38-11-41
ALL ú ú 03 Page 401 ú Nov 12/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500
MAINTENANCE MANUAL
FWD (EXAMPLE) LAVATORY ASEE PIPING WATER
(4 LOCATIONS) [3] SCREW
BSEE DRAIN VALVE VALVE [1] DRAIN
(2 LOCATIONS) [2] TUBING CONNECTION [4] BRACKET
A WATER PIPING B DRAIN VALVE
Lavatory Water Drain Installation
Figure 401
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
38-11-41
ALL ú ú 02 Page 402 ú Nov 12/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 WATER AND WASTE(17)
