POTABLE WATER SUPPLY
HOT WATER TUBING OUTLET CONNECTOR
MOUNTING BRACKET
WATER HEATER
WATER SUPPLY
INLET CONNECTOR

LAVATORY DRAIN VALVE
Water Heater Installation
Figure 401

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 38-11-61
 ALL  ú ú 01 Page 402 ú Mar 12/01
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 S 024-010
 (4)  Remove the water heater.
 TASK 38-11-61-404-012
 3. Water Heater Installation (Fig. 401)
_________________________
 A. Access
 (1)  Location Zones
 103 Forward Lavatory
 113/114 Aft Lavatory
 118 Lavatory (if installed)

 B. Procedure
 S 424-013
 (1)  
Put the water heater in the sink cabinet.

 S 434-014

 (2)  
Install the water heater into the attach clamp.

 S 434-015

 (3)
Connect the inlet and the outlet tubes to the water heater.

 S 434-016

 (4)
Connect the electrical connector into the compartment wall.

 S 794-017

 (5)  
Turn the lavatory drain valve to the ON position and examine for water leaks.

 S 864-018
 CAUTION: DO NOT SUPPLY ELECTRICAL POWER TO THE WATER HEATER UNTIL THE
_______ WATER HEATER IS FULLY FILLED WITH WATER. DAMAGE TO THE WATER HEATER CAN OCCUR IF IT IS NOT FULLY FILLED WITH WATER.
 (6)  
Remove the DO-NOT-CLOSE tag and close the applicable LAVATORY WATER HEATER circuit breaker on the P18-4 panel.

 (7)  
Turn the water heater switch to the ON position.

 S 864-019
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 38-11-61
 ALL  ú ú 01 Page 403 ú Jul 15/97
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 S 864-022
 (8)  
Make sure the indicator light on the water heater comes on.

 S 864-023

 (9)  
After five minutes, make sure you get hot water from the hot water faucet.

 S 824-025

 (10)
 WATER HEATERS WITH TEMPERATURE SELECT SWITCH; If the water is not at the correct temperature, move the temperature select switch to a higher or lower temperature position.

 C. Put the Airplane to Its Usual Condition
 S 414-020
 (1)  Close the door for the sink cabinet.
 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 38-11-61
 ALL  ú ú 01 Page 404 ú Jul 15/97
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
737-300/400/500MAINTENANCE MANUAL
 WASHBASIN FAUCET - MAINTENANCE PRACTICES
________________________________________
 1.  General
_______
 A.  The washbasin faucet can be repaired to stop the water leakage. You must repair or replace the cartridge valve below the faucet handle to repair the water leakage.
 TASK 38-11-81-302-001
 2.  Water Faucet Repair (Fig. 201)
___________________
 A.  Access
 (1)  Location Zones
 103 Forward Lavatory
 113/114 Aft Lavatory
 118 Lavatory (if installed)

 B.  Procedure
 S 002-033
 (1)  AIRPLANES WITH WEBER LAVATORY FAUCETS;
 Do these steps to remove the cartridge:

 (a)  
Examine the water faucet for leaks.

 (b)  
Turn the lavatory drain valve to the OFF position.

 (c)  
Lift the faucet handle to the vertical position.

 (d)  
Install a wrench to the hexnut and remove the cartridge from the body assembly.

 (e)  
Examine the cartridge valve and replace the O rings if required.

 NOTE: If the cartridge valve surface that seals is not
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 WATER AND WASTE(22)