71-00-02
ALL ú ú C05B Page 466 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
Power Plant Removal - Bootstrap Method
______________________________________ Remove the Power Plant
S 094-127-C00
(12) If it is necessary, remove the bootstrap equipment from the strut.
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
71-00-02
ALL ú ú C13B Page 467 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
ENGINE
CRADLE ASSEMBLY
TRANSPORTATION BASE
Removed Engine With Attached Cradle Assembly and Transportation Stand
Figure 420
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
71-00-02
ALL ú ú C20B Page 468 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
C78492
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
Prepare For the Installation of the Power Plant
_______________________________________________
TASK 71-00-02-864-148-C00
4. Prepare For the Installation of the Power Plant
_______________________________________________
A. General
(1)
This task does a check to make sure the configuration of the replacement engine and the airplane are equivalent.
B.
References
(1)
AMM 71-21-02/401, Forward Engine Mount Thrust Link Assembly
C.
Access
(1)
Location Zone
506 Engine No. 1
606 Engine No. 2
507 Strut No. 1
607 Strut No. 2
D.
Prepare For the Installation of the Power Plant
S 864-149-C00
CAUTION: DO A CHECK OF THE COMPATIBILITY BETWEEN THE AIRPLANE AND ENGINE
_______ AS FOLLOWS BEFORE YOU DO THE POWER PLANT INSTALLATION PROCEDURE. IF THE AIRPLANE AND ENGINE ARE NOT COMPATIBLE, DAMAGE TO THE EQUIPMENT CAN OCCUR.
(1) Do the steps below to make sure the configurations of the airplane and the engine are equivalent:
NOTE: To do a check for the compatibility of the engine and the
____ airplane, you must look at these areas:
-AVM system compatibility
-
Engine/Strut electrical connections
-
Engine/Strut vibration isolators
-Pneumatic control logic and W1508 wire bundle
-Engine/strut interference compatibility
-Fuel control box compatibility
-Engine fire protection system
(a) AVM system compatibility requirements.
1) Do a check of the compatibility between the engine turbine rear frame (TRF) vibration sensor (mounted on the TRF flange at the 11:30 o'clock position) and the airplane AVM signal conditioner (located in the main E/E rack on the E1-2 shelf) with this table:
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
71-00-02
ALL ú ú C18B Page 469 ú Mar 12/02
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / /
CFM56 ENGINES
737-300/400/500/ /MAINTENANCE MANUAL ////////////////////////
Prepare For the Installation of the Power Plant
_______________________________________________
~.................................................................. | AVM SYSTEM COMPATIBILITY REQUIREMENTS | .................................................................... | TRF VIBRATION SENSOR | AVM SIGNAL CONDITIONER | | (SENSITIVITY) | | .................................................................... | | BOEING P/N S332T304( ) | | 20 pC/g | -16 | | 50 pC/g | -23, -25, -26, -27, or -30 | .................................................................... | 50 pC/g | BOEING P/N S360N021-100,-102,-201 | 2..............................…...................................1
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：737-300 400 500 AMM 飛機維護手冊 動力裝置 POWER PLANT 1(128)
