with a thicker shim if it is necessary.
 NOTE: It is necessary to drill holes in a new shim for
____ the bolts and the roll pins.
 d)  Apply the BMS 10-11 primer to the mating surfaces of
 the shim.
 e) Assemble the hinge assembly.
 f) Install the pressure relief vent.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 71-11-03
 ALL  ú ú N01 Page 507 ú Oct 10/97
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
FAN COWL PANEL - MAINTENANCE PRACTICES (OPENING/CLOSING)
________________________________________________________
 1.  General
_______
 A.  There are two tasks in this procedure. The first task opens the fan cowl panels, and the second task closes the fan cowl panels. These two tasks are for the inboard and the outboard fan cowl panels.
 B.  The hold-open rod and the stabilizer rod hold the fan cowl panel open. The one end of the rods attaches to the fan cowl panel with a bolt. The other end of the rods attaches to a stow bracket on the fan cowl panel when the fan cowl panel is closed. When the fan cowl panel is open, the aft rod attaches to a bracket on the fan case and the forward rod attaches to a bracket on the aft bulkhead of the inlet cowl. The rods extend when the fan cowl panel opens.
 C.  When the rods are fully extended, it is necessary to lock the rods. If the rods are not locked, an injury can occur.
 TASK 71-11-04-012-001-N00
 2.  Open the Fan Cowl Panel (Fig. 201)
_______________________
 A.  References
 (1)  
IPC 71-11-04 Fig. 1

 B.  
Access

 (1)  
Location Zone
 413 and 414 Fan Cowl Panel - Engine 1
 423 and 424 Fan Cowl Panel - Engine 2
 433 and 434 Fan Cowl Panel - Engine 3
 443 and 444 Fan Cowl Panel - Engine 4

 C.  
Procedure

 S 012-018-N00
 CAUTION: USE CAUTION WHEN YOU REMOVE THE FAN COWL PANELS IN LARGE WINDS
_______ OR IN SUDDEN HIGH WINDS. IF YOU DO NOT USE CAUTION, INJURY TO PERSONS OR DAMAGE TO EQUIPMENT CAN OCCUR.
 CAUTION: DO NOT HOLD THE FAN COWL PANELS OPEN WITH THE HOLD-OPEN RODS IF
_______ THE WIND VELOCITY IS MORE THAN 60 KNOTS. THE HOLD-OPEN RODS CAN HAVE A FAILURE IN LARGE WINDS WHICH CAN CAUSE INJURY TO PERSONS OR DAMAGE TO EQUIPMENT.
 (1) Do these steps to open the latches on the fan cowl panels:
 (a)  
Open the forward latch. 1) Push the trigger to release the handle. 2) Pull the handle down to release the latch.

 (b)  
Use the same steps to open the other latches from the front of the fan cowl to the rear.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 71-11-04
 ALL  ú ú N01 Page 201 ú Jun 18/00
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
////////////////////////A / PW4000 SERIES /747-400 / ENGINES /MAINTENANCE MANUAL ////////////////////////
SEE A
FAN COWL 
PANEL 
SEE  D 
STABILIZER ROD 
SEE  C 
HOLD-OPEN ROD 
ENGINE FAN  SEE  F SEE  E 
CASE  SEE  B 
HOLD-OPEN 
ROD 
RECEIVER 
BRACKET FOR 
THE HOLD- FWD 
OPEN ROD
COLLAR  A 

FWD
B
Fan Cowl Panel Opening Figure 201 (Sheet 1)
EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 71-11-04
 ALL  ú ú N01 Page 202 ú Jun 10/91
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
SECONDARY LOCK 
INLET COWL TAI DUCT 
1 
STABILIZER ROD  LOCKING SLEEVE 
LOCKED 
BRACKET FOR THE STABLIZER ROD RECEIVER  D  SECONDARY LOCK 
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 動力裝置 POWER PLANT 2(69)