%
Doc # 6.02.01 Page 201
Rev. 4 09 Jan 2003
80-01-00
AMM
% B. Install the ELECTRIC MASTER Key Switch % %
% % % %
% % % % %
% % %
%
%
% %
% %
%
%
%
DA 40 Series
Detail Steps/Work Items Key Items/References
WARNING: MAKE SURE THAT THE ENGINE IS SAFE BEFORE YOU DO ANY WORK ON THE STARTER SYSTEM. IF THE ENGINE STARTS THE PROPELLER CAN CAUSE INJURY OR DEATH.
(1) Make sure that the engine is safe: S Set the ELECTRIC MASTER key switch to OFF. S Set the ENGINE MASTER switch to OFF. S Set the power lever to IDLE.
(2) Put the ELECTRIC MASTER key switch in position between the instrument panel and the firewall.
(3) Connect the cables to the ELECTRIC MASTER key switch Refer to the wiring diagrams and the notes you made during removal.
(4) Move the ELECTRIC MASTER key switch into position in the instrument panel.
(5) Install the retaining nut to the cockpit side of the ELECTRIC MASTER key switch.
(6) Install the instrument panel cover. Refer to Section 25-10.
(7) Connect the airplane main battery. Refer to Section 24-34.
(8) Install the engine top cowling. Refer to Section 71-11.
(9) Do an engine ground run-up. Refer to Section 71-01.
%
80-01-00
Starting
AMM
% 3. Remove/Install the ENGINE MASTER Switch
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
%
% A. Remove the ENGINE MASTER Switch %
Detail Steps/Work Items Key Items/References
WARNING: MAKE SURE THAT THE ENGINE IS SAFE BEFORE YOU DO ANY WORK ON THE STARTER SYSTEM. IF THE ENGINE STARTS THE PROPELLER CAN CAUSE INJURY OR DEATH.
(1) Make sure that the engine is safe: S Set the ELECTRIC MASTER key switch to OFF. S Set the ENGINE MASTER switch to OFF. S Set the power lever to IDLE.
(2) Remove the engine top cowling. Refer to Section 71-11.
(3) Disconnect the airplane main battery. Refer to Section 24-34.
(4) Remove the instrument panel cover. Refer to Section 25-10.
(5) Release the retaining nut from the cockpit side of the ENGINE MASTER switch.
(6) Move the ENGINE MASTER switch towards the front of the airplane.
(7) Disconnect the cables from the ENGINE MASTER switch Make a note of the position of the cables.
(8) Remove the ENGINE MASTER switch from the airplane.
%
Doc # 6.02.01 Page 203
Rev. 4 09 Jan 2003
80-01-00
AMM
% B. Install the ENGINE MASTER Switch % %
% % % %
% % % % %
% %
%
%
% %
% %
%
%
%
DA 40 Series
Detail Steps/Work Items Key Items/References 中國航空網 www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：鉆石40飛機維護手冊 DA 40 SERIES AMM 6(24)
