(2)
Put the safety barriers in position.
(3)
Put the warning notice(s) in position to tell persons not to pressurize the Blue hydraulic system:
-in the cockpit on the hydraulic section 40VU of the overhead panel, - on the ground service panel of the Blue hydraulic system.
(4)
Make sure that the Blue hydraulic system is depressurized and put it in the maintenance configuration. (Ref. TASK 29-00-00-864-001).
(5)
Depressurize the reservoir of the Blue hydraulic system (Ref. TASK 29-14-00-614-001).
WARNING : MAKE SURE THAT THE RAT TRAVEL RANGE IS CLEAR BEFORE YOU
_______
EXTEND/RETRACT THE RAT.
(6) Extend the Ram Air Turbine (RAT) (Ref. TASK 29-22-00-869-005).
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 29-22-53Page 458 1301-399, 401-499, 1Config-1 Aug 01/05 1 1 1CES 1
Subtask 29-22-53-010-064
B. Get Access
(1)
Open the access door 195BB.
(2)
Open the left main gear door (Ref. TASK 32-12-00-010-001).
(3)
Remove the access panel 147BB.
(4)
Remove the access panel 147CB.
(5)
Remove the protective cover from the RAT compartment as follows: (Ref. Fig. 407/TASK 29-22-53-991-016)
(a)
Loosen the screws (2) from the quick-release fasteners (3).
(b)
Remove the screw (5) from the protective cover (1).
(c)
Remove the protective cover (1) from the RAT compartment (4). Subtask 29-22-53-865-088
C.
Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------
49VU HYD/RAT/CTL 2801GE D14 106VU CSM/G /EV/MAN/SPLY 6XE B04 121VU HYDRAULIC/RAT/SPLY/EXTN/SOL1 2803GE P33
4. Procedure
_________
(Ref. Fig. 407/TASK 29-22-53-991-016) Subtask 29-22-53-020-064
A. Removal of the RAT Stowed Switch
(1)
Disconnect the electrical connector (7).
(2)
Put protective caps on the disconnected electrical connectors.
(3)
Cut, remove and discard the lockwire from the stowed switch (6).
(4)
Remove the stowed switch (6).
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 29-22-53Page 459 1301-399, 401-499, 1Config-1 Aug 01/05 1 1 1CES 1
RAT Stowed Switch
Figure 407/TASK 29-22-53-991-016
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 29-22-53Page 460 1301-399, 401-499, 1Config-1 Aug 01/05 1 1 1CES 1
(5) Put a blanking cap in the open port of the ejection jack (8).
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 29-22-53Page 461 1301-399, 401-499, 1Config-1 Aug 01/05 1 1 1CES 1 TASK 29-22-53-400-014
Installation of the RAT Stowed Switch
WARNING : PUT THE SAFETY DEVICES AND THE WARNING NOTICES IN POSITION BEFORE YOU
_______ START A TASK ON OR NEAR:
-
THE FLIGHT CONTROLS
-
THE FLIGHT CONTROL SURFACES
-
THE LANDING GEAR AND THE RELATED DOORS
-COMPONENTS THAT MOVE.
WARNING : MAKE SURE THAT THE TRAVEL RANGES OF THE FLIGHT CONTROL SURFACES ARE
_______ CLEAR BEFORE YOU PRESSURIZE/DEPRESSURIZE A HYDRAULIC SYSTEM.
WARNING : MAKE SURE THAT THE GROUND SAFETY-LOCKS ARE IN POSITION ON THE LANDING
_______ GEAR.
1. Reason for the Job
__________________
Self Explanatory
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific blanking cap No specific ohmmeter No specific safety barriers No specific warning notices No specific Torque Wrench : range 0.00 to 1.20 m.daN
(0.00 to 9.00 lbf.ft)
B. Consumable Materials
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
Material No. 19-010 USA AMS 5687 LOCKWIRE STAINLESS STEEL ANNEALED 0.8MM DIA (Ref. 20-31-00)
R 1EFF : 062-099, 106-149, 151-199, 204-299, 1 29-22-53Page 462 1301-399, 401-499, 1Config-1 Aug 01/05 1 1 1CES 1
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM HYDRAULIC POWER 液壓6(60)
