52-32-16
 ALL  ú ú 02 Page 403 ú Feb 10/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400
MAINTENANCE MANUAL

 (b)  
Install the upper end fitting of the safety strut in the midspan door latch.

 (c)  
Lock the upper end fitting in position with the pin through the fitting and the locking pin hole in the door latch.

 (d)  
Turn the elliptical fitting on the lower end fitting to make sure the slot is at the lower end.

 (e)  
Open the door to align the lower end fitting with the midspan latch pin.

 WARNING:_______ YOU MUST USE THE ELLIPTICAL FITTING ON THE LOWER END
 FITTING OF THE SAFETY STRUT.  IF YOU USE THE CIRCULAR
 HOLE, THE LOWER END FITTING WILL NOT LOCK TIGHTLY ON THE
 ELLIPTICAL MIDSPAN LATCH PIN.  THIS CAN CAUSE DAMAGE TO
 THE LOWER END FITTING.  THIS CAN ALSO CAUSE INJURY IF THE

 SAFETY STRUT DISENGAGES.
 (f)  
Install the elliptical fitting of the lower end fitting on the midspan latch pin.

 (g)  
Tighten the capscrew on the lower end fitting

 (h)  
Use the hydraulic pump to push the door a small distance in the open direction.

 (i)  
Tighten the capscrew on the lower end fitting again.

 (j)  
Move the pump and the hose clear of the cargo loading area.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 52-32-16
 ALL  ú ú 02 Page 404 ú Feb 10/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A
747-400 MAINTENANCE MANUAL
 RAIN SEAL - REMOVAL/INSTALLATION
________________________________
 1. General
_______
 A. This procedure contains two tasks:
 (1)  
The removal of the rain seal from the side cargo door.

 (2)  
The installation of the rain seal on the side cargo door.

 TASK 52-32-18-004-001
 2. Remove the Rain Seal
____________________
 A. References
 (1)  
IPC 52-32-18 Fig. 2

 B.
Access

 (1)  
Location Zone
 261 Main Deck STA 1720 To STA 2040, LH

 (2)  
Access Panels
 836L Door - Main Deck Cargo

 C.
Remove the rain seal (Fig. 401)

 S 864-014
 WARNING: MAKE SURE THAT PERSONS AND EQUIPMENT ARE AWAY FROM THE DOOR AND
_______ THE DOOR OPENING WHEN YOU OPERATE THE DOOR. FAILURE OF THE LIFT MECHANISM COULD CAUSE THE DOOR TO CLOSE QUICKLY WHICH COULD CAUSE INJURY OR DAMAGE.
 (1)
Put the door in the necessary position to remove the rain seal.

 (2)  
Remove the screw that holds the rain seal to the door.

 S 024-015

 (3)  
Apply a stable pull on the rain seal to remove the seal from the door structure.

 (4)  
Make sure you do not damage the seal and the retainer.

 S 034-004
 S 214-016
 NOTE: The seal retainer is bonded to the seal and must be removed
____
 with the seal.

 EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú

 52-32-18
 ALL  ú ú 02 Page 401 ú Feb 10/94
BOEING PROPRIETARY - Copyright (C) - Unpublished Work - See title page for details.
A 747-400 MAINTENANCE MANUAL 
A 
DOOR HINGE  A 

SEAL-TO-FUSELAGE CONNECTION
SEE A  DOORFWD HINGE
RAIN SEAL
(FOLDED)
RAIN SEAL
SEAL-TO-DOOR  (EXTENDED)
CONNECTION
SEE B DOOR IN THE
CLOSED POSITION DOOR IN THE OPEN POSITION
A-A
SEAL SCREW RETAINER
SEAL SUPPORT
NUTPLATE ANGLE RAIN SEAL FUSELAGE STRUCTURE
SEAL
DOOR RETAINER
RAIN
NUTPLATE SCREW SEAL
SEAL-TO-FUSELAGE CONNECTION  SEAL-TO-DOOR CONNECTION
A B
Rain Seal
Figure 401

EFFECTIVITYùùùùùùùùùùùùùùùùùùùùùùùùùùùùùù. ú
　
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：747-400 AMM 飛機維護手冊 艙門 DOORS 2(175)