C. Fill reservoir of the PUMP HAND COWL - ACTUATOR, FAN REVERSER (HIX4001) with Mobil Jet Oil RM 254 (Material No. CP2442).
Subtask 78-36-00-480-050
D. Connect the Hose WARNING : SUDDEN CLOSURE OF HALF DOORS COULD CAUSE SERIOUS INJURY TO
_______ PERSONNEL. ALL PERSONNEL MUST BE CLEAR OF AREA UNDER AND BETWEEN HALF DOORS DURING OPENING OR CLOSING OF REVERSER.
F 『 EEFF : ALL E Page 20378-36-00
E E Aug 01/98 E E ECES E F 『 E C F M E E E E 56-5B E
Thrust Reverser Door Latches
Figure 201/TASK 78-36-00-991-300
F 『 EEFF : ALL E Page 20478-36-00
E E Feb 01/98 E E ECES E F 『 E C F M E E E E 56-5B E
Hydraulic Hand Pump Installation
Figure 202/TASK 78-36-00-991-301
F 『 EEFF : ALL E Page 20578-36-00
E E Feb 01/98 E E ECES E
F 『
E C F M E
E E
E 56-5B E
E E
(1) Connect the hose of hand pump to the quick disconnect on the hydraulic junction box.
Subtask 78-36-00-010-052
E. Operate the hand pump to open the half door to 35 degrees position as follows: (Ref. Fig. 203/TASK 78-36-00-991-302)
WARNING : YOU MUST HOLD EACH HALF DOOR OPENED WITH THE HOLD-OPEN ROD TO
_______ PREVENT SERIOUS INJURY DUE TO ACCIDENTAL CLOSURE.
(1) Remove the quick release pin that attach the hold-open rod on the upper bracket.
(2) Move the hold-open rod to the bracket of the forward frame.
(3) Attach the hold-open rod with the quick-release pin.
Subtask 78-36-00-010-053
F. Open the half door to 45 degrees position as follows:
(Ref. Fig. 203/TASK 78-36-00-991-302)
WARNING : SUDDEN CLOSURE OF HALF DOORS COULD CAUSE SERIOUS INJURY TO
_______ PERSONNEL. ALL PERSONNEL MUST BE CLEAR OF AREA UNDER AND BETWEEN HALF DOORS DURING OPENING OR CLOSING OF REVERSER.
WARNING : YOU MUST HOLD EACH HALF DOOR OPENED WITH THE HOLD-OPEN ROD TO
_______ PREVENT SERIOUS INJURY DUE TO ACCIDENTAL CLOSURE.
CAUTION : RETRACT WING SLATS BEFORE OPENING THRUST REVERSER OR DAMAGE CAN
_______
OCCUR.
(1) Operate the hand pump to open the half door to 45 degrees position.
R (2) Remove the red bolt and nut from the lug of the top lug of the hold
R open rod attach fitting on the inner cowl. Put the nut on the bolt
R and tighten.
R (Ref. Fig. 203/TASK 78-36-00-991-302)
R (Sheet 2, Detail D).
R (3) Remove the quick release pin that attach the hold open rod on the lower bracket.
R (4) Move the hold-open rod to the bracket of forward frame.
F 『 EEFF : ALL E Page 20678-36-00
E E Aug 01/02 E E ECES E
F 『
E C F M E
E E
E 56-5B E
E E
R (5) Attach the hold open rod with the quick release pin. Subtask 78-36-00-680-050
G. Drain the fluid from the door opening actuator. NOTE : The fluid should always be drained from the actuator, if not,
____ there will not be enough fluid in the pump to open the other door. If more fluid is added to the pump there will be too much fluid in the pump when the door is closed.
(1) Open the relief valve on the PUMP HAND COWL - ACTUATOR, FAN REVERSER (HIX4001).
(2) Let the fluid in the actuator drain into the hand pump for a minimum of one minute.
Subtask 78-36-00-080-050
H. Disconnect the Hose of the Hand Pump from the Quick Disconnect on the Hydraulic Junction Box
Subtask 78-36-00-420-050
J. Put the Cap on the Quick Disconnect
F 『 EEFF : ALL E Page 20778-36-00
E E Aug 01/02 E E ECES E F 『 E C F M E E E E 56-5B E F 『 E C F M E E E E 56-5B E
R Hold-Open Rod Installation Figure 203/TASK 78-36-00-991-302- 12 (SHEET 1)
F EEFF : E E ECES ALL 『E 78-36-00EEE Page 208 Aug 01/02
R Hold-Open Rod Installation Figure 203/TASK 78-36-00-991-302- 22 (SHEET 2)
F EEFF : E E ECES ALL 『E 78-36-00EEE Page 209 Aug 01/02
F 『
E C F M E
E E
E 56-5B E
E E
TASK 78-36-00-410-040
Closing of the Thrust Reverser Doors
1. Reason for the Job
__________________
Self Explanatory
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------
中國航空網 www.k6050.com
航空翻譯 www.aviation.cn
本文鏈接地址：A320飛機維護手冊 AMM EXHAUST 2(97)
