FAIRING - FLAPS - REMOVAL/INSTALLATION
______________________________________
R **ON A/C 001-049, 051-099, 101-149, 151-199, 201-299, 401-499,
TASK 57-55-11-000-001
Removal of the Flap Track Fairings Nos. 2, 3 and 4
WARNING : PUT THE SAFETY DEVICES AND THE WARNING NOTICES IN POSITION BEFORE YOU
_______
START A TASK ON OR NEAR:
-
THE FLIGHT CONTROLS
-
THE FLIGHT CONTROL SURFACES
-
THE LANDING GEAR AND THE RELATED DOORS
-COMPONENTS THAT MOVE.
WARNING : MAKE SURE THAT THE GROUND SAFETY-LOCKS ARE IN POSITION ON THE LANDING
_______
GEAR.
1. Reason for the Job
__________________
Self Explanatory
2. Job Set-up Information
______________________
A. Fixtures, Tools, Test and Support Equipment
-------------------------------------------------------------------------------REFERENCE QTY DESIGNATION -------------------------------------------------------------------------------
No specific circuit breaker(s) safety clip(s)
No specific safety barriers
No specific warning notices
No specific adjustable access platform 4 m (13 ft. 1 in.)
98D27803500001 1 TOOL-ZERO LOCKING, FLAP SLAT CTL LEVER
B. Referenced Information
-------------------------------------------------------------------------------REFERENCE DESIGNATION -------------------------------------------------------------------------------
27-50-00-866-009 Retraction of the Flaps on the Ground 57-55-11-991-023 Fig. 401 57-55-11-991-001 Fig. 402 57-55-11-991-002 Fig. 403 57-55-11-991-003 Fig. 404
3. Job Set-up
__________ Subtask 57-55-11-941-051
A. Safety Precautions
(1) Put warning notices in the cockpit to tell persons not to operate the flaps or slats.
(2) Put the safety barriers in position. Subtask 57-55-11-860-057
B. Aircraft Maintenance Configuration
(1)
Make sure that the flaps are fully retracted (Ref. TASK 27-50-00-866-009).
(2)
Install the TOOL-ZERO LOCKING, FLAP SLAT CTL LEVER (98D27803500001) on the flap/slat control-lever.
(3)
Put the adjustable access platform in position below the applicable fairing at flap track 2, 3 or 4, zone 531(631), 532(632) or 533(633).
Subtask 57-55-11-865-050
C. Open, safety and tag this(these) circuit breaker(s):
-------------------------------------------------------------------------------PANEL DESIGNATION IDENT. LOCATION -------------------------------------------------------------------------------49VU FLIGHT CONTROLS/FLP/CTL AND MONG/SYS1 6CV B07 121VU FLIGHT CONTROLS/FLP/CTL AND/MONG/SYS2 8CV Q21
R 1EFF : 001-049, 051-099, 101-149, 151-199, 1 57-55-11Page 402 1201-299, 401-499, 1Aug 01/05 1 1 1CES 1
4. Procedure
_________ (Ref. Fig. 401/TASK 57-55-11-991-023, 402/TASK 57-55-11-991-001, 403/TASK 57-55-11-991-002, 404/TASK 57-55-11-991-003) Subtask 57-55-11-020-050
A. Removal of the Flap Track Fairing CAUTION : YOU MUST FOLLOW THESE STEPS OF THE PROCEDURE ACCURATELY. THIS
_______ WILL PREVENT DAMAGE TO THE PARTS.
(1) Remove the applicable forward fixed fairing 531AB(631AB) or 532AB(632AB) or 533AB(633AB):
(a)
Remove the bolts (2).
(b)
Carefully move the forward fixed fairing forward, to disengage the spigot (3) from its keyhole plate. Hold the forward fixed fairing until the bonding strap (1) has been disconnected.
NOTE : The forward fixed fairing is connected, through the
____ bonding strap (1), to the support bracket of the aft fixed fairing.
(c)
For the track 2 and the track 3 positions, remove the nut (20), the bolt (13) and disconnect the bonding straps (1) and (19).
(d)
For the track 4 position, remove the bolt (22) and disconnect the bonding straps (1) and (21).
(2) Remove the applicable aft fixed fairing 531BB(631BB), or 532BB(632BB) or 533BB(633BB):
(a) Remove the applicable covers (4):
1_ For the track 2 position, remove the screws (5) and the covers
(4) 531AR(631AR), 531AL(631AL).
2_ For the track 3 position, remove the screws (5) and the covers
(4) 532AR(632AR), 532AL(632AL).
3_ For the track 4 position, remove the screws (5) and the covers
(4) 533AR(632AR), 533AL(633AL).
R 1EFF : 001-049, 051-099, 101-149, 151-199, 1 57-55-11Page 403 1201-299, 401-499, 1Aug 01/05 1 1 1CES 1 中國航空網 www.k6050.com 航空翻譯 www.aviation.cn 本文鏈接地址：A320飛機維護手冊 AMM WINGS 機翼5(52)
